Daily Archives: August 10, 2019

10 August 1961

Republic F-105D-5-RE Thunderchief 58-1173 carrying sixteen 750-pound M117 general purpose bombs. (U.S. Air Force)

10 August 1961: A Republic F-105 Thunderchief lifted the largest load ever carried aloft by a single-engine aircraft when it carried a payload of over 14,000 pounds (6,350.3 kilograms) during a test.

In this photograph, F-105D-5-RE Thunderchief 58-1173 is loaded with sixteen 750-pound M117 general purpose bombs, which actually weigh approximately 820 pounds (372 kilograms) each.

A color image of F-105D 58-1173. (U.S. Air Force)
A color image of F-105D 58-1173. (U.S. Air Force)

The Thunderchief is the largest single seat, single engine aircraft ever built. It was a Mach 2 fighter-bomber, designed for NATO defensive tactical nuclear strikes with a nuclear bomb carried in an internal bomb bay. It is best known, though, as a fighter bomber used in the Vietnam War. Because of its very high speed it was employed as a “Wild Weasel”, attacking surface-to-air missile sites.

A color image of F-105D 58-1173 from below. (U.S. Air Force)
A color image of a Republic F-105 Thunderchief, possibly 58-1173, seen from below. (U.S. Air Force)

Republic Aviation Corporation built 833 F-105 Thunderchief fighter bombers at its Farmingdale, New York factory. 610 of those were single-seat F-105Ds. The F-105D Thunderchief was 64 feet, 3 inches (19.583 meters) long (excluding pitot boom) with a wingspan of 34 feet, 11 inches (10.643 meters) and overall height of 19 feet, 8 inches (5.994 meters). It had an empty weight of 26,622 pounds (12,076 kilograms) and a maximum takeoff weight of 50,511 pounds (22,911 kilograms).

The F-105D wings were swept 45° at 25% chord. The angle of incidence was 0° and there was no twist. The wings had 3° 30′ anhedral. The total wing area was 385 square feet (35.8 square meters).

The Thunderchief was powered by one Pratt & Whitney J75-P-19W engine. The J75 is a two-spool axial-flow afterburning turbojet with water injection. It has a 15-stage compressor section (8 low- and and 7 high-pressure stages) and 3-stage turbine section (1 high- and 2 low-pressure stages.) The J75-P-19W is rated at 14,300 pounds of thrust (63.61 kilonewtons), continuous power; 16,100 pounds (71.62 kilonewtons), Military Power (30-minute limit); and Maximum Power rating of 24,500 pounds (108.98 kilonewtons) with afterburner (15-minute limit). The engine could produce 26,500 pounds of thrust (117.88 kilonewtons) with water injection, for takeoff. The J75-P-19W is 21 feet, 7.3 inches (6.586 meters) long, 3 feet, 7.0 inches (1.092 meters) in diameter, and weighs 5,960 pounds (2,703 kilograms).

The maximum speed of the F-105D was 734 knots (845 miles per hour/1,360 kilometers per hour)—Mach 1.11—at Sea Level, and 1,210 knots (1,392 miles per hour, 2,241 kilometers per hour)—Mach 2.11—at 35,000 feet (10,668 meters). The combat ceiling was 51,650 feet (15,743 meters) and maximum unrefueled ferry range was 1,928 nautical miles (2,218 statute miles/3,571 kilometers).

The F-105D was armed with one 20 mm M61A1 Vulcan rotary cannon and 1,028 rounds of ammunition. It had an internal bomb bay and could carry bombs, missiles or fuel tanks on under wing and centerline hardpoints. The maximum bomb load consisted of sixteen 750-pound (340 kilogram) bombs. For tactical nuclear strike missions, the F-105D could carry one Mk-28 “special store” in the internal bomb bay.

The F-105 Thunderchief was designed as a supersonic tactical fighter bomber rather than an air superiority fighter. Still, during the Vietnam War F-105s shot down 27 enemy MiG fighters. 24 of those were shot down with the Thunderchief’s Vulcan cannon.

Of the 833 F-105s, 395 were lost during the Vietnam War. 334 were shot down, mostly by antiaircraft guns or missiles, and 17 by enemy fighters. Another 61 were lost due to accidents. The 40% combat loss is indicative of the extreme danger of the missions these airplanes were engaged in.

Republic F-105D-30-RE (S/N 62-4234) in flight with full bomb load. (U.S. Air Force photo)
Republic F-105D-30-RE Thunderchief 62-4234 with a full bomb load. (U.S. Air Force)

© 2018, Bryan R. Swopes

Facebooktwitterredditpinterestlinkedinmailby feather

10–11 August 1938

The Focke-Wulf Fw 200 S-1 Condor, D-ACON, arrives at Floyd Bennett Field, New York, 11 August 1938. (Klassiker fer Luftfahrt)

10–11 August 1938: The first non-stop flight between Berlin and New York by a heavier-than-air aircraft was flown by a prototype four-engine airliner. Under the command of Deutsche Luft Hansa Kapitän Alfred Henke, Brandenburg, a Focke-Wulf Fw 200 S-1 Condor, D-ACON, departed Flugplatz Berlin-Staaken, 6 kilometers west of Spandau, at about 7:30 p.m., on Wednesday, 10 August 1938.

The other members of the crew were Hauptmann Rudolf Freiherr von Moreau, of the Luftwaffe, co-pilot; Paul Dierberg, flight engineer; and Walter Kober, radio operator. There were no passengers on board.

Brandenburg flew a Great Circle course across the North Atlantic Ocean and landed at Floyd Bennett Field, Brooklyn, New York at 1:50 p.m., local time, Thursday, 11 August. The distance flown was 6371.302 kilometers (3,958.944 miles). The total duration of the flight was 24 hours, 56 minutes, 12 seconds. The Condor averaged 255.499 kilometers per hour (158.760 miles per hour).

Focke-Wulf Fw 200 S-1 Condor D-ACON at Floyd Bennett Field, New York, 11 August 1938. (Deutsche Lufthansa AG)

Although they encountered severe weather, the flight was relatively uneventful. Upon landing, it was discovered that the prototype airliner had suffered some damage to an engine cowling and that one engine lubricating oil tube had cracked, causing a leak.

Focke-Wulf Fw 200S-1 Kondor (Condor) D-ACON on the ground in front of Hangar 4 at Floyd Bennett Field, Long Island, New York. (Rudy Arnold Collection/National Air and Space Museum)

The problems were repaired while Hauptman von Moreau made an unexplained trip to Washington, D.C. Brandenburg was ready for a return flight to Germany the following day.

Manifest for Focke-Wulf Fw 200 S-1 Condor D-ACON.

Taking off from Floyd Bennett Field before 9:30 a.m., on Saturday, 13 August, Brandenburg was flown to Flughafen Berlin-Templehof. With more favorable winds on the eastbound flight, the 6,392 kilometer distance (3,972 miles) was covered in 19 hours, 56 minutes, with an average speed of 321 kilometers per hour (199 miles per hour).

 

14. August 1938. Deutschlands Ozeanflieger nach Ihrem Rekordflug Berlin-New York-Berlin auf dem Flughafen Tempelhof. V.l.: Kober, Dierberg, Henke und von Moreau. Foto: Deutsche Lufthansa AG 14.08.1938 DLHD5054-1-35

Following their return to Germany, Captain Henke (who was also an Oberleutnant in the Luftwaffe) and Hauptman von Moreau were congratulated by Adolph Hitler. In photographs, Henke is easily identifiable by the prominent “dueling scar” on the left side of his face.

Kurt Waldemar Tank, March 1941. (Bundesarchiv)

D-ACON was the prototype Condor, designated Fw 200 V1, Werk-Nr. 2000. It had first flown at Neulander Feld, site of the Focke-Wulf plant in Bremen, 27 July 1937. The test pilot was Kurt Waldemar Tank, an aeronautical engineer and the airplane’s designer.

Tank had proposed the airplane to Deutsche Luft Hansa as a long-range commercial transport for routes from Europe to South America. While British and American airlines were using large four-engine flying boats for transoceanic flight, their heavy weight and aerodynamic drag reduced the practical passenger and cargo loadings. A lighter-weight, streamlined land plane would be faster and could carry more passengers, increasing its desirability and practicality. Also, while the flying boats had to make an emergency water landing if one engine failed during the flight, the Focke-Wulf Condor was designed to be able to remain airborne with just two engines.

Prototype Focke-Wulf Fw 200 V1 Condor, Werk-Nr. 2000, D-ACON (Klassiker fer Luftfahrt)

The Fw 200 V1 was an all-metal low-wing monoplane powered by four engines, with retractable landing gear. It had a flight crew of four, and was designed to carry a maximum of 26 passengers. It was 78 feet, 0 inches (27.774 meters) long with a wingspan of 108 feet, 0 inches (32.918 meters) and overall height of 20 feet, 0 inches (6.096 meters). The airliner had an empty weight of 24,030 pounds (10,900 kilograms) and gross weight of 37,479 pounds (17,000 kilograms). This increased to 39,683 pounds (18,000 kilograms) after modification to the Fw 200 S-1 configuration.

As originally built, the prototype Condor was powered by four air-cooled, supercharged 1,690.537-cubic-inch-displacement (27.703 liters) Pratt & Whitney Hornet S1E-G single-row 9-cylinder radial engines with a compression ratio of 6.5:1 and gear reduction ratio of 3:2. The S1E-G was rated at 750 horsepower at 2,250 r.p.m. to 7,000 feet (2,134 meters), and 875 horsepower at 2,300 r.p.m. for takeoff. It was 4 feet, 1.38 inches (1.254 meters) in diameter, 4 feet, 6.44 inches (1.383 meters) long, and weighed 1,064 pounds (483 kilograms).

Prototype Focke-Wulf Fw 200 V1 Condor, Werk-Nr. 2000, D-ACON. (Bernhard D.F. Klein Collection/1000 Aircraft Photos)

Brandenburg‘s Pratt & Whitney engines were later replaced by Bayerische Motorenwerke AG BMW 132 L engines. BMW had been producing licensed variants of the Pratt & Whitney Hornet since 1933, and had incorporated their own developments during that time.

The Fw 200 V1 had a maximum speed of 233 miles per hour (375 kilometers per hour) at Sea Level. Its cruising speed was 205 miles per hour (330 kilometers per hour) at 10,000 feet (3,048 meters). The airliner’s service ceiling was 20,000 feet (6,096 meters). It could maintain level flight at 13,000 feet (3,962 meters) with 3 engines, and 10,000 feet (3,048 meters) with just two engines running. Its range at cruise speed with a 7,000 pound (3,175 kilogram) payload was 775 miles (1,247 kilometers).

For the Berlin-to-New York flight, the Fw 200’s fuel capacity was increased to 2,400 gallons (9,084 liters).

D-ACON made a series of long distance flights to demonstrate its potential. On 20 November 1938, Brandenburg flew from Berlin to Hanoi in French Indo-China (now, the Socialist Republic of Vietnam). The crew was the same as the Berlin-New York flight, with the addition of G. Khone. This flight set a Fédération Aéronautique Internationale (FAI) World Record for Speed Over Courses of 243.01 kilometers per hour (151.00 miles per hour).¹

Focke-Wulf Fw 200 S-1 Condor, D-ACON. (Klassiker fer Luftfahrt)

On 6 December 1938, while on approach to Manila, capital city of the Commonwealth of the Philippines, all four of D-ACON’s engines stopped. Unable to reach the airfield, the Condor was ditched in Manila Bay. All aboard were quickly rescued. The cause of the engines failing was fuel starvation. One source states that the crew had selected the wrong tanks. Another source says that a fuel line had broken. A third cites a fuel pump failure.

Focke-Wulf Condor D-ACON after ditching near Manila, 6 Dec 1938 (Bureau d’Archives des Accidents d’Avions)

The wreck of the first Condor was recovered, however, the airplane was damaged beyond repair.

Recovery of Focke-Wulf Fw 200 S-1 Condor D-ACON. (Bureau d’Archives des Accidents d’Avions)

While the Focke-Wulf Fw 200 had been designed as a civilian airliner, it soon found use as a long-range maritime patrol bomber. The Fw 200 V10 was a military variant requested by the Imperial Japanese Navy. With the outbreak of World War II, Condors were produced as both bombers and transports. They saw extensive service searching for and attacking the Allies’ transatlantic convoys.

Focke-Wulf Fw 200 C-3 Condor, SG+KS, Werk-Nr. 0043. (World War Photos)
A Luftwaffe Focke-Wulf Fw 200 C-3 Condor reconnaissance bomber, SG+KS, Werk-Nr. 0043, circa 1941. (Photograph by Walter Frentz. Bundsarchiv, Bild 146-1987-043-02)

¹ FAI Record File Number 8984

© 2018, Bryan R. Swopes

Facebooktwitterredditpinterestlinkedinmailby feather

10 August 1912

Lieutenant Colonel Sir Francis Kennedy McLean, A.F.C., 18 September 1919. (Flight)
Lieutenant Colonel Sir Francis Kennedy McLean, A.F.C., 18 September 1919. (Flight)

10 August 1912: Frank McLean (later, Lieutenant Colonel Sir Francis Kennedy McLean, A.F.C.) flew his modified Short S.33 float plane, and, according to his obituary in the London Times, 12 August 1955, “. . . created a record by flying up the Thames in a seaplane, passing between the upper and lower parts of Tower Bridge and under London Bridge without touching the water.”

The vertical distance between the upper walkways and the deck of the draw bridge is 141 feet, 0 inches (42.977 meters).

Diagram of Tower Bridge, with dimensions. (Wikipedia)
Diagram of Tower Bridge, with dimensions. (Wikipedia)

Flight reported the event:

By Hydro-aeroplane up the Thames

     ALTHOUGH London was deprived by the appalling weather of the sight of M. Beaumont piloting his hydro-aeroplane up the Thames, the visit of Mr. F.K. McClean more than compensated for the loss. Remembering an appointment in town on Saturday morning, Mr. McClean thought it would be a good idea to come up on his Short machine, and so at 6 a.m. he had it out of its shed at Harty Ferry, in the Isle of Sheppey, and after seeing everything in order he started off. Following the coast round Leysdown, Warden Point to Sheerness, he continued over the Thames. At Gravesend the smoke of various factories rather troubled the aviator but he made good progress. Approaching London Mr. McClean brought his machine lower down and negotiated the Tower Bridge between the lower and upper spans, but the remaining bridges to Westminster he flew underneath, the water just being touched at Blackfriars and Waterloo bridges. He reached Westminster about 8.30 and was taken ashore to Westminster Pier on a Port of London Launch.

The return journey on Sunday afternoon was not so successful—owing to restrictions as to rising from the water which had been imposed by the police. The bridges had all been safely negotiated, and when near Shadwell Basin Mr. McClean started to manœuver to get into the air at the point designated by the river authorities. He had made one circuit when the machine side-slipped, and either through hitting a barge or by sudden contact with the water one of the floats was damaged. The machine was then towed into Shadwell Dock, this operation being superintended by Mr. McClean from the driving seat, and dismantled for its return by road to Eastchurch.

FLIGHT, No. 190. (No 33, Vol. IV.) 17 August 17 1912 at Page759, Column 1

Frank McLean flying through the Tower Bridge, 10 August 1912. (Clan Maclean)
Frank McLean flying through the Tower Bridge, 10 August 1912. (Clan Maclean Heritage Trust)

The Short S.33 was a variant of the S.27 biplane, built specifically for McLean. It is a two-place, single-engine four-bay biplane with the engine in a pusher configuration. An elevator is forward. Although it had been fitted with two floats for operating from the water, McLean had it converted to a land plane by installing two wheels on a tube axle attached to the lower wing with four struts. Two wooden skids are also installed. The fuselage is an open rectangular framework. At the aft end is a horizontal stabilizer and elevator, and two rudders. There were two tail skids.

The Short S.33 was 36 feet, 0 inches (10.973 meters) long (following conversion) with an upper wingspan of 70 feet, 6 inches (21.488 meters). The upper wing had a maximum chord of 6 feet, 7 inches.  The outer 16 feet (4.877 meters) of the upper wing was swept aft and had a slight dihedral, as did the outer panels of the lower wings. The lower wing had a shorter wingspan and narrower chord—5 feet, 9 inches (1.753 meters)—than the upper wing. The biplane had a gross weight of 1,600 pounds (725.75 kilograms)

The S.33 was powered by an air-cooled 10.292 liter (628.048-cubic-inch-displacement) Société des Moteurs Gnome Gamma 7-cylinder rotary engine producing 70 horsepower at 1,200 r.p.m. It turned a two-bladed, fixed-pitch wooden propeller with a diameter of 8 feet, 6 inches (2.591 meters) through direct drive.

Three-view diagram of Frank McLean's "70-H.P. Short biplane.: (FLIGHT, No. 232. (No. 23, Vol. V.), 7 June 1913 at Page 614)
Three-view diagram of Frank McLean’s “70-H.P. Short biplane.” (FLIGHT, No. 232. (No. 23, Vol. V.), 7 June 1913 at Page 614)

Sir Francis was a civil engineer, astronomer, pioneering photographer and aviator. He received the Royal Aero Club’s Aviator Certificate Number 21 on 20 September 1910.

McLean served in the Royal Naval Air Service during World War I and became an officer of the Royal Air Force when RNAS and the Royal Flying Corps were combined in 1918. He is considered to be the founder of the Fleet Air Arm. McLean was decorated with the Air Force Cross in 1919.

For his services to aviation, McLean was knighted by George V, 3 July 1926 and later appointed High Sheriff of Oxfordshire.

Sir Francis McLean died 11 August 1955 at London, England, after a lengthy illness. He was 79 years old.

Francis McLean’s Short S.33 biplane, which he used to fly through and under bridges on the Thames, 10 August 1912.

© 2017, Bryan R. Swopes

Facebooktwitterredditpinterestlinkedinmailby feather