5 November 1959

The Number 2 X-15, 56-6671, broke in half when it made an emergency landing while still partially loaded with propellants. (NASA)
The Number 2 X-15, 56-6671, broke in half when it made an emergency landing while still partially loaded with propellants. (NASA)

5 November 1959: During his fourth X-15 flight—the third in the Number Two ship, 56-6671—North American Aviation chief test pilot Albert Scott Crossfield made an emergency landing at Rosamond Dry Lake after one of the two Reaction Motors XLR11-RM-13 rocket engines exploded, causing an engine compartment fire.

The X-15 had been launched by the Boeing NB-52A Stratofortress, 52-003, at 0.82 Mach and approximately 45,000 feet (13,716 meters) over Bouquet Canyon Reservoir, about 35 miles (56 kilometers) southwest of Edwards Air Force Base. Scott Crossfield ignited both XLR11 rocket engines and began to accelerate and climb, but one of four combustion chambers of the lower engine exploded almost immediately. He shut both engines down after 11.7 seconds. Crossfield kept the rocketplane in a level attitude for the 114 seconds it took to jettison the liquid oxygen and water-alcohol propellants to lighten the X-15 for the landing. The tanks could not fully drain and the aircraft remained approximately 1,000 pounds (455 kilograms) overweight.

The X-15 approached the emergency landing site at Rosamond Dry Lake, about ten miles (16 kilometers) southwest of Edwards, while Major Robert M. White, flying a Lockheed F-104 chase plane, called out Crossfield’s distance from the dry lake and his altitude. As he neared the touch down point, Crossfield raised the X-15’s nose to decelerate.

“I lowered the skids and nose wheel, pulled the flaps, and felt for the lake bed.

“The skids dug in gently. The nose wheel slammed down hard and the ship plowed across the desert floor, slowing much faster than usual. Then she came to a complete stop within 1500 feet instead of the usual 5000 feet. Something was wrong; the skids failed, I was sure. . . Quickly I scrambled out of the cockpit. What I saw almost broke my heart. The fuselage had buckled immediately aft of the cockpit, two hundred and thirty inches back from the nose. Her belly had dragged in the sand, causing the abrupt deceleration on the lake. The rocket chambers which had exploded at launch were a shambles.”

Always Another Dawn: The Story of a Rocket Test Pilot, by A. Scott Crossfield and Clay Blair, Jr., The World Publishing Company, Cleveland and New York, 1960, Chapter 41 at Pages 383–384.

The scene at Rosamond Dry Lake after Scott Crossfield's emergency landing after an engine explosion. (NASA)
The scene at Rosamond Dry Lake after Scott Crossfield’s emergency landing following an engine explosion. (NASA)

It was determined that the engine had exploded due to an ignition failure, a relatively simple problem not connected to the design of the X-15. But there remained the question as to why the rocketplane had broken in half. The investigation found that the rapid extension of the nose wheel strut when lowered caused the oil inside the strut to foam and vaporize, providing almost no shock absorption. This was corrected and the check list changed to lower the gear sooner.

The total duration of this flight was 5 minutes, 28.0 seconds. The peak altitude was 45,462 feet (13,857 meters) and the maximum speed was 660 miles per hour (1,062 kilometers per hour).

56-6671 was taken back to the North American Aviation plant for repair. It returned to flight operations three months later.

Test pilot A. Scott Crossfield with the damaged X-15 (UPI/Harry Ransom Center
Test pilot A. Scott Crossfield with the damaged X-15 on Rosamond Dry Lake. (UPI/Harry Ransom Center, University of Texas at Austin)

© 2016, Bryan R. Swopes

Share this article:

5 thoughts on “5 November 1959

  1. great story and I gotta say, I don’t think they aid these guys enough but with obvious great flying skills and love of flight I guess he was happy ?

Comments are closed.