Tag Archives: Atlas LV-3B

20 February 1962, 14:47:39 UTC

Launch of Friendship 7 from Launch Complex 14, Kennedy Space Center, 14:47:39 UTC, 20 February 1962. (NASA)

20 February 1962: At 9:47:39 a.m., Eastern Standard Time, NASA’s Mercury-Atlas 6 lifted off from Launch Complex 14, Cape Canaveral Air Force Station, Cape Canaveral, Florida. This was the third launch of a manned Mercury spacecraft, and the first time that an Atlas rocket had been used.

Aboard the spacecraft was Lieutenant Colonel John Herschel Glenn, Jr., United States Marine Corps, an experienced fighter pilot and test pilot.

John Herschel Glenn, Jr., NASA Project Mercury Astronaut. (Ralph Morse/LIFE Magazine)

In his post-flight mission report, Glenn wrote,

When the countdown reached zero, I could feel the engines start. The spacecraft shook, not violently but very solidly. There was no doubt when lift off occurred, When the Atlas was released there was an immediate gentle surge to let you know you were on your way.

Results of the First United States Orbital Space Flight (NASA-TM-108606), Manned Spacecraft Center, National Aeronautics and Space Administration, at Page 120, Column 1

2 minutes, 9.6 seconds after liftoff, the booster engines cut of and were jettisoned. 23 seconds later, the escape tower, no longer needed, was also jettisoned. The Atlas sustainer engine continued to burn until T+00:05:01.4. The spacecraft had now reached 17,544 miles per hour (28,234 kilometers per hour) and was in an elliptical orbit around the Earth. At T+00:05:03.6 the Mercury spacecraft separated from the Atlas booster. During the climb to orbit, John Glenn experienced a maximum acceleration of 7.7 gs.

Glenn’s orbit had an apogee of 162.2 statute miles (261 kilometers) and perigee of 100 miles (161 kilometers). The orbit was inclined 32.54° relative to Earth’s orbital plane. Friendship 7 completed an orbit every 88 minutes, 29 seconds.

Analysis showed that the Atlas had placed Friendship 7 in orbit at a velocity with 7 feet per second (2.1 meters per second) less than nominal. However, computer analysis showed that the orbital trajectory was good enough for nearly 100 orbits.

This photograph of Friendship 7’s cockpit was taken in orbit around the Earth, 20 February 1962. Astronaut John Glenn’s hands and legs are visible at the lower edge of the image. (Ohio State University)

During the 4 hour, 55 minute, 23 second flight, the Mercury capsule orbited the Earth three times. John Glenn was the first American astronaut to orbit the Earth.  (Cosmonaut Yuri Gagarin had orbited the Earth 12 April 1961.)

Friendship 7 is hoisted aboard USS Noa (DD-841). (U.S. Navy)

After re-entry, the capsule parachuted into the Atlantic Ocean, only six miles from the recovery ship, USS Noa (DD-841).

Mercury spacecraft profile with dimensions. (NASA)

The Mercury spacecraft, Friendship 7, was built by McDonnell Aircraft Corporation, St. Louis, Missouri. It was the 13th Mercury capsule built. Designed to carry one pilot, it could be controlled in pitch, roll and yaw by steam thrusters fueled by hydrogen peroxide. The Mercury was 7 feet, 2.83 inches (2.206 meters) long, not including its retro rocket pack. The spacecraft was generally conical, and had a maximum diameter of 6 feet, 2.50 inches (1.885 meters). It weighed 2,700 pounds (1,224.7 kilograms) at launch.

Diagram of Atlas LV-3B (Space Launch Report)

The rocket, a “1-½ stage” liquid-fueled Atlas LV-3B, number 109-D, was built by the  Convair Division of General Dynamics at San Diego, California. It was developed from a U.S. Air Force SM-65 Atlas D intercontinental ballistic missile, modified for use as a “man-rated” orbital launch vehicle.

The LV-3B was 65 feet (19.812 meters) long from the base to the Mercury adapter section, and the tank section is 10 feet (3.038 meters) in diameter. The complete Mercury-Atlas orbital launch vehicle is 93 feet (28.436 meters) tall, including the escape tower. When ready for launch it weighed approximately 260,000 pounds (118,000 kilograms) and could place a 3,000 pound (1,360 kilogram) payload into low Earth orbit.

The Atlas’ three engines were built by the Rocketdyne Division of North American Aviation, Inc., at Canoga Park, California. Two Rocketdyne LR89-NA-5 engines and one LR105-NA-5 produced 341,140 pounds (1,517.466 kilonewtons) of thrust. The rocket was fueled by a highly-refined kerosene, RP-1, with liquid oxygen as the oxidizer.

Friendship 7 is displayed at the Smithsonian National Air and Space Museum.

John Glenn's Mercury spacecraft, Friendship 7, on display at the Smithsonian Institution National Air and Space Museum. (Photo by Eric Long, National Air and Space Museum, Smithsonian Institution.)
John Glenn’s Mercury spacecraft, Friendship 7, on display at the Smithsonian Institution National Air and Space Museum. (Photo by Eric Long, National Air and Space Museum, Smithsonian Institution.)

© 2019, Bryan R. Swopes

3 October 1962, 12:15:12 UTC, T minus Zero

Mercury-Atlas 8 lifts off from Cape Canaveral, Florida, 3 October 1962. (NASA)
Mercury-Atlas 8 lifts off from Launch Complex 14, Cape Canaveral Air Force Station, Cape Canaveral, Florida, 12:15:12 UTC, 3 October 1962. (NASA)

3 October 1962: At 08:15:12 a.m., Eastern Daylight Time, Commander Walter M. Schirra, Jr., United States Navy, lifted off from Cape Canaveral, Florida, aboard Mercury-Atlas 8 (MA-8). This was the fifth U.S. manned space flight and the third orbital flight.

The spacecraft, which Wally Schirra had named Sigma 7, entered a low earth orbit with the altitude varying from 84 nautical miles (156 kilometers) to 154 nautical miles (285 kilometers). Each orbit took 88 minutes, 54.6 seconds.

Schirra experimented with the manual flight control systems, took photographs and performed spatial-orientation exercises. There were some difficulties with the cooling of his pressure suit.

Wally Schirra took this photograph of Earth while in orbit over South America, 3 October 1962. (Walter M. Schirra, Jr./NASA)
Wally Schirra took this photograph of Earth while in orbit over South America, 3 October 1962. (Walter M. Schirra, Jr./NASA)

Sigma 7 completed 6 orbits and at T+8:52, fired the retro rockets to de-orbit. Reentry was successful and Sigma 7 landed within 0.5 miles (0.8 kilometers) of the primary recovery ship, the aircraft carrier USS Kearsarge (CVS-33).

The Mercury spacecraft, named Sigma 7, was built by McDonnell Aircraft Corporation, St. Louis, Missouri. It was the 16th Mercury capsule built. Designed to carry one pilot, it could be controlled in pitch, roll and yaw by thrusters. It was 9 feet, 7.72 inches (2.939 meters) long, and, bell-shaped, had a maximum diameter of 6 feet, 2.5 inches (1.885 meters). The spacecraft weighed 2,700 pounds (1,224.7 kilograms) at launch.

Wally Schirra, wearing a B.F. Goodrich full-pressure suit, is helped into the Sigma 7 Mercury capsule. (NASA)

The rocket, a “1-½ stage”, liquid-fueled Atlas LV-3B, number 113-D, was built by Convair at San Diego, California. It was developed from a U.S. Air Force Atlas D intercontinental ballistic missile, modified for use as a “man-rated” orbital launch vehicle. The LV-3B was 94.3 feet (28.7 meters) tall with a maximum diameter of 10.0 feet (3.05 meters). When ready for launch it weighed 260,000 pounds (120,000 kilograms) and could place a 1,360 kilogram payload into Low Earth orbit. The Atlas’ three engines were built by the Rocketdyne Division of North American Aviation, Canoga Park, California. The XLR89 booster had two 150,000 pound thrust chambers, and the LR105 sustainer engine produced 57,000 pounds of thrust. The rocket was fueled by a highly-refined kerosene, RP-1, with liquid oxygen as the oxidizer.

Mercury-Atlas 8 stands on the pad at Launch Complex 14 on the morning of 3 October 1962. (NASA)

Schirra was the first astronaut to wear an Omega Speedmaster chronograph during spaceflight. (Omega Reference No. CK2998). The Speedmaster would become flight-qualified by NASA, and the Speedmaster Professional is known as the “moon watch.”

Sigma 7 is on display at the U.S. Astronaut Hall of Fame, Titusville, Florida, near the Kennedy Space Center.

Wally Schirra commanded Gemini 6A during the orbital rendezvous mission with Gemini 7. Later, he commanded Apollo 7, an 11-day orbital mission.

Captain Walter M. Schirra, Jr., USN, died 3 May 2007 at the age of 84 years.

Commander Walter M. Schirra, Jr., United States Navy. (NASA)
Commander Walter M. Schirra, Jr., United States Navy. (NASA)

© 2015, Bryan R. Swopes

24 May 1962, 12:45:16 UTC, T plus 00:00:00.57

MA-7 liftoff, 12:45:16 UTC, 24 May 1962. (NASA)

24 May 1962: Lieutenant Commander Malcolm Scott Carpenter, United States Navy, NASA Astronaut, was launched aboard Mercury-Atlas 7 at 12:45:16.57 UTC (7:45:16 a.m., Eastern Daylight Time) from Launch Complex 14 at the Cape Canaveral Air Force Station, Cape Canaveral, Florida. This was the fourth manned space flight of the American space program. Carpenter was the sixth human to fly in space.

Scott Carpenter reported,

When the ignition signal was given, everything became quiet. I had expected to feel the launch vehicle shake, some machinery start, the vernier engines light off, or to hear the lox valve make some noise, but I did not. Nothing happened until main engine ignition; then I began to feel vibration. There was a little bit of shaking. Lift off was unmistakable.

RESULTS OF THE SECOND U.S. MANNED ORBITAL SPACE FLIGHT MAY 24, 1962, NASA SP-6. National Aeronautics and Space Administration, Manned Spacecraft Center, Project Mercury. Pilot’s Flight Report, Page 69, Column 2

According to the NASA post-flight mission report, “The performance of the launch vehicle was exceptionally good. . . .”

MA-7, Aurora 7, lifts of from Launch Complex 14, Cape Canaveral Air Force Station, Florida, at 7:45:16 a.m., EST, 24 May 1962. (NASA)

During the launch, Carpenter experienced a maximum of 7.8 gs acceleration. 5 minutes, 12.2 seconds after liftoff, Aurora 7 separated from the Atlas booster and entered Earth orbit, having reached a speed of 17,534 miles per hour (28,219 kilometers per hour). The orbit was elliptical, with a minimum altitude of 86.87 nautical miles (160.88 kilometers) and a maximum of 144.96 nautical miles (268.47 kilometers). Carpenter completed an orbit every 88 minutes, 32 seconds.

Carpenter, Malcolm Scott, Lieutenant Commander, United States Navy, NASA Astronaut, 22 October 1964. (National Aeronautics and Space Administration S64-34357)

During the orbital phase of the mission, a pitch horizon scanner—part of the automatic flight control system—malfunctioned, causing the capsule’s attitude jets to fire to correct perceived errors in the ship’s attitude. This caused an excessive consumption of the hydrogen peroxide fuel for the reaction controls.

At T+04:30:00 (four hours, thirty minutes after launch) the Mercury capsule’s retrorockets fired to slow the capsule and begin the reentry phase of the flight. Each of the retro rockets fired at 5 second intervals and burned for 10 seconds. The capsule decelerated 550 feet per second (168 meters per second) and fell out of orbit. The PHS failed again, yawing Aurora 7 25° off track, which prevented the full thrust of the retrorockets from being directed along the correct path. Scott Carpenter had to fire the rockets manually, resulting in a 3 second delay, and this, along with the misalignment of the capsule, caused Aurora 7 to overshoot the planned splashdown point in the Atlantic ocean by approximately 250 nautical miles (288 statute miles/463 kilometers). (N. 19° 27′, W. 63° 59′)

At 10,000 feet (3,048 meters) Aurora 7‘s main parachute opened. The spacecraft “splashed down” at 17:41:21 UTC. The total duration of the flight was 4 hours, 55 minutes, 57 seconds.

Scott Carpenter was hoisted aboard a Sikorsky HSS-2 Sea King helicopter from USS Intrepid (CVS-11). Aurora 7 was recovered by the Allan M. Sumner-class destroyer, USS John R. Pierce (DD-753), 6 hours after its landing.

A Sikorsky HSS-2 Sea King, Bu. No. 148964, hoists Scott Carpenter from Aurora 7. (U.S. Navy)

The flight of Scott Carpenter and Aurora 7 was a success, but Carpenter was subject to criticism for his performance during the mission.

In 1963, Carpenter was injured in a motorcycle accident and lost some mobility in his left arm. Despite two surgical procedures, it was determined that he was ineligible for spaceflight. He resigned from NASA in 1967 and retired from the U.S Navy in 1969 with the rank of Commander.

Carpenter enters Aurora 7. (NASA)

Mercury 18, named Aurora 7 by Carpenter, was built by McDonnell Aircraft Corporation, St. Louis, Missouri. Designed to carry one pilot, the Mercury space craft could be controlled in pitch, roll and yaw by thrusters. The space capsule was truncated cone with sides angled 20° from the longitudinal axis. It was 6 feet, 10 inches (2.083 meters) long and had a maximum diameter of 6 feet, 2.50 inches (1.892 meters). The total height of the spacecraft, from the tip of the aero spike to the booster adapter, was 26 feet, 1.26 inches (7.957 meters). Aurorra 7 weighed 4,244.09 pounds ( kilograms) at Launch.

The rocket, a “1-½ stage” liquid-fueled Atlas LV-3B, number 107-D, was built by the  Convair Division of General Dynamics at San Diego, California. It was developed from a U.S. Air Force SM-65 Atlas D intercontinental ballistic missile, modified for use as a “man-rated” orbital launch vehicle.

The LV-3B was 65 feet (19.812 meters) long from the base to the Mercury adapter section, and the tank section is 10 feet (3.038 meters) in diameter. The complete Mercury-Atlas orbital launch vehicle is 93 feet (28.436 meters) tall, including the escape tower. When ready for launch it weighed approximately 260,000 pounds (117,934 kilograms).

Diagram of Atlas LV-3B (Space Launch Report)

The Atlas’ three engines were built by the Rocketdyne Division of North American Aviation, Inc., at Canoga Park, California. Two Rocketdyne LR89-NA-5 engines and one LR105-NA-5 produced 341,140 pounds (1,517.466 kilonewtons) of thrust. The rocket was fueled by a highly-refined kerosene, RP-1, with liquid oxygen as the oxidizer.

Malcolm Scott Carpenter died 10 October 2013 at the age of 88. His spacecraft, Aurora 7, is on display at the Chicago Museum of Science and Industry, Lakeshore Drive, Chicago, Illinois.

© 2019, Bryan R. Swopes

15 May 1963, 13:04:13.106 UTC, T plus 00:00:00.106

Mercury Atlas 9 (MA-9), consisting of Faith 7 and Atlas 130-D, lifts off from Launch Complex 14 at the Cape Canaveral Air Force Station, Florida, at 13:04:13 UTC, 15 May 1963. (NASA)

15 May 1963: At 8:04:13.106 a.m., Eastern Standard Time, Mercury-Atlas 9, carrying NASA astronaut, L. Gordon Cooper aboard Faith 7, lifted off from Launch Complex 14, Cape Canaveral Air Force Base, Florida. Cooper reported, “The liftoff was smooth, but very definite, the acceleration was very pleasant. The booster had a very good feel to it and it felt like we were real on the go, there.” The maximum acceleration experienced during launch was 7.6 gs.

Faith 7 separated from the Atlas booster at T+00:05:05.5.3 and entered low Earth orbit with an apogee of 165.9 statute miles (267.0 kilometers) and perigee of 100.3 statute miles (161.4 kilometers). The orbital period was 88 minutes, 45 seconds. The spacecraft’s velocity was 25,714.0 feet per second (7,837.6 meters per second), or 17,532.3 miles per hour (28,215.5 kilometers per hour).

Major L. Gordon Cooper, Jr., United States Air Force. NASA Astronaut. (March 6, 1927 – October 4, 2004). Major Cooper is wearing a modified U.S. Navy Mark IV full-pressure suit produced by B.F. Goodrich. (NASA)

MA-9 was the final flight of Project Mercury. Gordon Cooper flew 22.5 orbits. Due to electrical system problems that began on the 21st orbit, he had to fly a manual reentry which resulted in the most accurate landing of the Mercury program.

The spacecraft’s three retrorockets fired 5 second intervals beginning at T+33:59:30. 34 hours, 19 minutes, 49 seconds after lift off, Faith 7 “splashed down” approximately 70 miles (112.7 kilometers) southeast of Midway Atoll in the North Pacific Ocean, just 4.4 miles (7.1 kilometers) from the primary recovery ship, the United States Navy Ticonderoga-class aircraft carrier USS Kearsarge (CV-33).

Mercury spacecraft profile with dimensions. (NASA)

The Mercury spacecraft, which Cooper named Faith 7, was built by McDonnell Aircraft Corporation, St. Louis, Missouri, which would also build the follow-on, two-place Gemini spacecraft. It was the 20th and final Mercury capsule to be built, and was one of four which were modified to support a day-long mission. Some items considered unnecessary were deleted and extra oxygen and battery capacity was added.

Designed to carry one pilot, the Mercury space craft could be controlled in pitch, roll and yaw by thrusters. The space capsule was truncated cone with sides angled 20° from the longitudinal axis. It was 6 feet, 10 inches (2.083 meters) long and had a maximum diameter of 6 feet, 2.50 inches (1.892 meters). The total height of the spacecraft, from the tip of the aero spike to the booster adapter, was 26 feet, 1.26 inches (7.957 meters). Faith 7 weighed 4,330.82 pounds (1,964.43 kilograms) at liftoff.

During flight outside the atmosphere, the Mercury spacecraft could be controlled in its pitch, roll and yaw axes by hydrogen peroxide-fueled reaction control thrusters. Both manual and automatic attitude control were available. It could not accelerate or decelerate (except for reentry) so it could not change its orbit.

The spacecraft cabin was pressurized to 5.5 psi with 100% oxygen. Gordon Cooper wore a modified  B.F. Goodrich Mark IV full-pressure suit and flight helmet for protection in the event that cabin pressure was lost. Cooper’s suit varied considerably from those worn by previous Mercury astronauts.

Mercury-Atlas 9 at Laucnh Complex 14. The gantry has been pulled back, but the rocket has not been filled with propellants. (NASA)
Mercury-Atlas 9 at Launch Complex 14. The gantry has been pulled back, but the rocket has not been filled with propellants. Two men at the lower right of the image provide scale.(NASA)

The rocket, a “1-½ stage” liquid-fueled Atlas LV-3B, number 130-D, was built by the  Convair Division of General Dynamics at San Diego, California. It was developed from a U.S. Air Force SM-65 Atlas D intercontinental ballistic missile, modified for use as a “man-rated” orbital launch vehicle.

The LV-3B was 65 feet (19.812 meters) long from the base to the Mercury adapter section, and the tank section is 10 feet (3.038 meters) in diameter. The complete Mercury-Atlas orbital launch vehicle is 93 feet (28.436 meters) tall, including the escape tower. When ready for launch it weighed approximately 260,000 pounds (117,934 kilograms).

Diagram of Atlas LV-3B with Metric dimensions. (Space Launch Report)

The Atlas’ three engines were built by the Rocketdyne Division of North American Aviation, Inc., at Canoga Park, California. Two Rocketdyne LR89-NA-5 engines and one LR105-NA-5 produced 341,140 pounds (1,517.466 kilonewtons) of thrust. The rocket was fueled by a highly-refined kerosene, RP-1, with liquid oxygen as the oxidizer.

Faith 7 is displayed at the Space Center Houston, the visitor center for the Johnson Space Flight Center, Houston, Texas.

Mercury-Atlas 9 at Launch Complex 14. (NASA GPN-2000-000609)

© 2019, Bryan R. Swopes