Tag Archives: D-558-I

25 August 1947

Major Marion E. Carl, USN, with a Douglas D-558-I Skystreak at Muroc Dry Lake, 1947. (U.S. Navy)
Major Marion E. Carl, USMC, with a Douglas D-558-I Skystreak at Muroc Dry Lake, 1947. (U.S. Navy)

25 August 1947: Major Marion Eugene Carl, United States Marine Corps, flying the Douglas D-558-I Skystreak, Bu. No. 37970, set a new Fédération Aéronautique Internationale (FAI) World Record for Speed Over a 3 Kilometer Straight Course, averaging 1,047.356 kilometers per hour (650.797 miles per hour).¹ The Skystreak was flown over a course laid out on Muroc Dry Lake, site of Muroc Army Air Field (now Edwards Air Force Base) in the high desert of Southern California.

Douglas D-558-I Skystreak Bu. No. 37970 makes a pass over the 3 kilometer course on Muroc Dry Lake. (U.S. Navy)
Douglas D-558-I Skystreak Bu. No. 37970 makes a pass over the 3 kilometer course on Muroc Dry Lake. (U.S. Navy)

Four passes were made over the course at an altitude of 200 feet (61 meters) or lower. Two runs were made in each direction to compensate for any head or tail winds. The official speed for a record attempt was the average of the two best consecutive passes out of the four.

Major Carl’s record exceeded one set by Commander Turner F. Caldwell, Jr., U.S. Navy, just five days earlier by 10.053 miles per hour (16.178 kilometers per hour).

Major Marion E. Carl, USMC, and Commander Turner F. Caldwell, Jr., USN, stand with the record-setting Douglas D-558-I Skystreak, Bu. No. 37970, on Muroc Dry Lake. (U.S. Navy)

The D-558 Program was intended as a three phase test program for the U.S. Navy and the National Advisory Committee on Aeronautics (NACA) to investigate transonic and supersonic flight using straight and swept wing aircraft powered by turbojet and/or rocket engines. The Douglas Aircraft Company designed and built three D-558-I Skystreaks and three D-558-II Skyrockets. The Phase I aircraft were flown by Douglas test pilot Eugene Francis (“Gene”) May, Navy Project Officer Commander Turner F. Caldwell, Jr., and Major Marion Carl.

Major Marion E. Carl, USMC; Gene May, Douglas Aircraft Company; Commander Turner F. Caldwell, USN.
Major Marion E. Carl, USMC; Gene May, Douglas Aircraft Company; Commander Turner F. Caldwell, USN.

The D-558-I Skystreak (also referred to as the D-558-1) was a single-engine, straight winged, turbojet-powered airplane. It was built of magnesium and aluminum for light weight, but was designed to withstand very high acceleration loads. It was 35 feet, 8 inches (10.871 meters) long with a wingspan of 25 feet, 0 inches (7.62 meters) and overall height of 12 feet, 1¾ inches (3.702 meters). The airplane had retractable tricycle landing gear. Its empty weight was approximately 7,500 pounds (3,400 kilograms), landing weight at the conclusion of a flight test was 7,711 pounds (3,498 kilograms). The maximum takeoff weight was 10,105 pounds (4,583.6 kilograms). The aircraft fuel load was 230 gallons (870.7 liters) of kerosene.

The D-558-I was powered by a single Allison J35-A-11 turbojet engine. The J35 was a single-spool, axial-flow turbojet with an 11-stage compressor section, 8 combustion chambers and single-stage turbine. The J35-A-11 was rated at 5,000 pounds of thrust (22.24 kilonewtons). The engine was 12 feet, 1.0 inches (3.683 meters) long, 3 feet, 4.0 inches (1.016 meters) in diameter and weighed 2,455 pounds (1,114 kilograms). The J35-A-11 was a production version of the General Electric TG-180, initially produced by Chevrolet as the J35-C-3. It was the first widely-used American jet engine.

The D-558-I had a designed service ceiling of 45,700 feet (13,930 meters). Intended for experimental flights of short duration, it had a very short range and took off and landed from the dry lake at Muroc. (After 1949, this would be known as Edwards Air Force Base.) The experimental airplane was not as fast as the more widely known Bell X-1 rocketplane, but rendered valuable research time in the high transonic range.

Gene May did reach Mach 1.0 in 37970, 29 September 1948, though he was in a 35° dive. This was the highest speed that had been reached up to that time by an airplane capable of taking off and landing under its own power.

The three D-558-I Skystreaks made a total of 229 flights and Bu. No. 37970 made 101 of them. After the Douglas test program was completed, -970 was turned over to NACA as NACA 140, but it was quickly grounded after the crash of the number two aircraft, and was used for spare parts for number three.

Today, 37970 is in the collection of the National Naval Aviation Museum at Naval Air Station Pensacola, Florida. The other surviving Skystreak, Bu. No. 37972, is at the Carolinas Aviation Museum, Charlotte-Douglas International Airport, Charlotte, North Carolina.

This painting depicts Major Marion E. Carl's speed record attempt over the 3 kilometer course at Muroc Dry Lake. (Steve Cox, 24" x 30", acrylic on board)
This painting depicts Major Marion E. Carl’s speed record attempt over the 3 kilometer course at Muroc Dry Lake. (Steve Cox, 24″ × 30″, acrylic on board)

¹ FAI Record File Number 9865

© 2017, Bryan R. Swopes