Tag Archives: Lycoming T53-L-1B

9 December 1959

December 9, 2023Aviation58-1848, FAI, Fédération Aéronautique Internationale, Helicopter, Kaman Aircraft Corporation, Kaman H-43B-KA Huskie, Lycoming T53-L-1B, Lycoming Turbine Engine Division, Walter J. Hodgson, William J. Davis, World Record for Altitude Without PayloadBryan Swopes

Captain Walter J. Hodgson (1924–1978) and Major William J. Davis, U.S. Air Force, with the world record-setting Kaman H-43B Huskie, 58-1848. (FAI)

9 December 1959: At Bloomfield, Connecticut, U.S. Air Force Captain Walter J. Hodgson and Major William J. Davis flew a Kaman H-43B-KA Huskie, 58-1848, to an altitude of 9,097 meters (29,845.8 feet), setting a Fédération Aéronautique Internationale (FAI) World Record for Altitude Without Payload.¹

The helicopter lifted off at 9:12 a.m., after a 1 hour, 12 minute weather delay, and reached its peak altitude at 10:30½. It landed back at Bloomfield after a flight of 1 hour, 53 minutes. 58-1848 was described as being in “mission configuration,” carrying all equipment for a normal operational flight. 58-1848 weighed 5,443 pounds (2,469 kilograms) at takeoff.

It was reported that this was the first altitude record for helicopters accomplished with two pilots on board.

Davis and Hodgson were presented with the Frederick L. Feinberg Award in 1960, for “demonstrating outstanding skills or achievement,” by the American Helicopter Society.

The Kaman Aircraft Corporation H-43 Huskie was a single-engine helicopter using a unique arrangement of counter-rotating and intermeshing rotors. The two rotors turning in opposite directions counteracted the torque effect, eliminating the need for a anti-torque tail rotor. In helicopters using a tail rotor, as much as 30% of the total engine power is used to drive the tail rotor. By eliminating that requirement, the total engine power could be used to produce lift. The Huskie could lift more weight and climb higher than a similar size helicopter with the same engine. Also, retreating blade stall was significantly reduced.

Flettner,Anton, 1885–1961. (Library of Congress) — Anton Flettner, 1885–1961. (Library of Congress)

The Kaman Huskie was designed by German inventor Anton Flettner. He had designed and built the Flettner Fl 282 Kolibri. He was brought to the United States at the end of World War II under Operation Paperclip, and went to work at Kaman Aircraft Corporation, Bloomfield, Connecticut.

The Huskie was used by the U.S. Air Force, U.S. Navy and Marine Corps, primarily for short range rescue operations. It was operated by two pilots and two rescue crewmen.

The fuselage of the H-43 was 25.0 feet (7.62 meters) long. Each rotor had a diameter of 47.0 feet (14.33 meters). The overall height was 15 feet, 6 inches (4.724 meters).

The H-43B was powered by one Lycoming T53-L-1B turboshaft engine, rated at 860 shaft horsepower at 21,510 r.p.m. The engine uses a 5-stage axial-flow, 1 stage centrifugal-flow, compressor with a single stage gas producer turbine and single-stage power turbine. A reverse-flow combustion section allows significant reduction in the the engine’s total length. The power turbine drives the output shaft through a 3.22:1 gear reduction. The T53-L-1 is 3 feet, 11.8 inches (1.214 meters) long and 1 foot, 11.0 inches (0.584 meters) in diameter. It weighs 460 pounds (209 kilograms).

The Huskie’s maximum speed was 107 miles per hour (172 kilometers per hour). Its hover ceiling in ground effect (HIGE) was 20,000 feet (6,096 meters) and it had a range of 250 miles (402 kilometers).

Kaman H-43B-KA Huskie 58-1848 was reclassified as HH-43B in 1962. It was retired to The Boneyard at Davis-Monthan Air Force Base, Tucson, Arizona, in 1972, and was scrapped in 1977.

Kaman H-43B-KA Huskie 58-1848 at Bloomfield, Connecticut, 9 December 1959. (FAI)

¹ FAI Record File Number 1869

5 July 1962

July 5, 2023Aviation60-0263, Chester R. Radcliffe Jr., FAI, Fédération Aéronautique Internationale, Helicopter, Hill Air Force Base, Kaman Aircraft Company, Kaman HH-43B Huskie, Lycoming T53-L-1B, National Museum of the United States Air Force, Pedro, Richard H. Coan, World Record for Distance Over a Closed Circuit Without Landing, World Record for Distance Without LandingBryan Swopes

Captain Clarence R. Radcliffe, Jr., United States Air Force (FAI) — Captain Chester R. Radcliffe, Jr., United States Air Force (FAI)

5 July 1962: Captain Chester R. Radcliffe, Jr., United States Air Force, flew Kaman HH-43B-KA Huskie 60-0263 from Hill Air Force Base, Utah, to Springfield, Minnesota, a distance of 1,429.80 kilometers (888.44 miles). This established a new Fédération Aéronautique Internationale (FAI) World Record for Distance Without Landing.¹

Captain Chet Radcliffe is congratulated on completion of the flight. The man in teh white shirt is Kaman Aircraft Company chief test pilot Andy Foster. (U.S. Air Force) — Captain Chet Radcliffe (right of center, wearing L-2B flight jacket) is congratulated on completion of the flight. The man in the white shirt is Kaman Aircraft Company Chief Test Pilot Francis Andrew Foster. (U.S. Air Force)

This same helicopter, flown by Captain Walter G. McMeen, set an FAI World Record for Altitude with a 1000 kilogram Payload to an altitude of 8,037 meters (26,368 feet) over the Kaman plant at Bloomfield, Connecticut, 25 May 1961.² On 18 October 1961, again at Bloomfield, Lieutenant Colonel Francis M. Carney set a World Record for Altitude Without Payload when he flew 60-0263 to 10,010 meters (32,841 feet).³ The following week, on 24 October 1961, Colonel Carney set six more world records, flying the HH-43B to 3,000 meters (9,853 feet) in 2 minutes, 41.5 seconds;⁴ 6,000 meters (19,685 feet) in 6 minutes 49.3 seconds;⁵ and to 9,000 meters (29,528 feet) in 14 minutes, 31 seconds.⁶ The following summer, Captain Richard H. Coan set an FAI World Record for Distance Over a Closed Circuit Without Landing when he flew 1,055.16 kilometers (655.65 miles) at Mono Lake, California, 13 June 1962.⁷

A turboshaft engine drove a unique system of counter-rotating and intermeshing rotors to provide lift, thrust and directional control. The counter-rotation cancelled the torque effect so no anti-torque, or tail, rotor was necessary. This allowed all of the engine’s power to drive the main rotor system.

The Huskie was used by the U.S. Air Force, U.S. Navy and Marine Corps, primarily for short range rescue operations. It was operated by two pilots and two rescue crewmen.

The fuselage of the H-43B was 25 feet, 2 inches (7.671 meters) long. Each rotor had a diameter of 47 feet, 0 inches (14.326 meters). It’s height was 15 feet, 6½ inches (4.737 meters). The helicopter’s empty weight was 4,470 pounds (2,028 kilograms) and its maximum gross weight was 8,800 pounds (3,992 kilograms).

The Huskie’s economical cruise speed was 98 miles per hour (158 kilometers per hour), and the maximum speed was 120 miles per hour (193 kilometers per hour). Its hover ceiling out of ground effect (HOGE) was 18,000 feet (5,486 meters), and in ground effect (HIGE) was 20,000 feet (6,096 meters) and it had a range of 235 miles (378 kilometers).

With the call sign Pedro, the HH-43 was a rescue helicopter that served in combat during the Vietnam War.

The record-setting Kaman HH-43B Huskie 60-0263 was last assigned to Detachment 3, 42nd Aerospace Rescue and Recovery Squadron, Kirtland Air Force Base, New Mexico. It is in the collection of the National Museum of the United States Air Force, Wright-Patterson Air Force Base, Ohio. Its distance record still stands.

Kaman HH-43B-KA Huskie 60-0263 at the National Museum of the United States Air Force. (U.S. Air Force)

¹ FAI Record File Number 1258

² FAI Record File Number 13154

³ FAI Record File Number 1870

⁴ FAI Record File Numbers 13057 and 13135

⁵ FAI Record File Numbers 13056 and 13136

⁶ FAI Record File Number 13137

⁷ FAI Record File Number 131258

13 June 1962

June 13, 2023Aviation42nd Aerospace Rescue and Recovery Squadron, 60-0263, FAI, Fédération Aéronautique Internationale, Helicopter, Kaman Aircraft Corporation, Kaman HH-43B Huskie, Lycoming T53-L-1B, Mono Lake, Pedro, Richard H. Coan, World Record for Altitude with a 1000 Kilogram Payload, World Record for Altitude Without Payload, World Record for Distance Over a Closed Circuit Without Landing, World Record for Time to Climb to a Height of 3000 Meters, World Record for Time to Climb to a Height of 6000 Meters, World Record for Time to Climb to a Height of 9000 MetersBryan Swopes

13 June 1962: At Mono Lake, California, Captain Richard H. Coan, United States Air Force, set a Fédération Aéronautique Internationale (FAI) World Record for Distance Over a Closed Circuit Without Landing with a specially prepared Kaman HH-43B Huskie, serial number 60-0263. With cowlings, doors and unneeded internal equipment removed—including brake lines to the rear wheels—the helicopter had an empty weight of just 5,300 pounds (2,404 kilograms).

Captain Richard H. Coan prepares to lift off aboard the HH-43B Huskie, 13 June 1962. (U.S. Air Force) — Near Mono Lake, California, Captain Richard H. Coan prepares to lift off aboard HH-43B-KA Huskie 60-0263, at dawn, 13 June 1962. (U.S. Air Force)

Flying along a 12-mile (19.3 kilometer) section of California Highway 167 (Pole Line Road) on the north shore of the lake, Captain Coan flew 27 laps in just over seven hours, until the Huskie ran out of fuel and settled to the pavement in a low-altitude autorotation. Without brakes and with the rear wheels locked, the helicopter rolled off the side of the roadway, but came to a stop before ending up in a ditch. The total distance flown was 1,055.16 kilometers (655.65 miles), a new Fédération Aéronautique Internationale (FAI) World Record for Distance Over a Closed Circuit Without Landing.¹

Kaman HH-43B Huskie 60-0263 parked at the edge of the roadway after it’s record-setting flight, at Mono Lake, California, 13 June 1962. (FAI) — Kaman HH-43B Huskie 60-0263 parked at the edge of Pole Line Road after its record-setting flight near Mono Lake, California, 13 June 1962. (FAI)

This same helicopter, flown by Captain Walter C. McMeen, set an FAI World Record for Altitude with a 1000 kilogram Payload to an altitude of 8,037 meters (26,368 feet) over Luke Air Force Base, Arizona, 25 May 1961.² On 18 October 1961, again at Bloomfield, Lieutenant Colonel Francis M. Carney set a World Record for Altitude Without Payload when he flew 60-0263 to 10,010 meters (32,841 feet).³ The following week, on 24 October 1961, Colonel Carney set six more world records, flying the HH-43B to 3,000 meters (9,853 feet) in 2 minutes, 41.5 seconds;⁴ 6,000 meters (19,685 feet) in 6 minutes 49.3 seconds;⁵ and to 9,000 meters (29,528 feet) in 14 minutes, 31 seconds.⁶ The following summer, Captain Chester R. Radcliffe, Jr., set an FAI World Record for Distance Without Landing when he flew it from Hill Air Force Base, Utah, to Springfield, Minnesota, a distance of 1,429.80 kilometers (888.44 miles), 5 July 1962.⁷

The Kaman Aircraft Corporation Huskie was used by the U.S. Air Force, U.S. Navy and Marine Corps, primarily for short range rescue operations. It was operated by two pilots and two rescue crewmen.

Captain Coan was awarded the Distinguished Flying Cross for the record flight. Later as a major, he commanded Detachment 8, 38th Aerospace Rescue and Recovery Squadron, at Cam Ranh Bay Air Base during the Vietnam War. He retired from the Air Force at the rank of lieutenant colonel.