Tag Archives: Manned Space Flight

11 November 1966, 20:46:33.419 UTC, T minus Zero

November 11, 2024Space FlightAgena Target Vehicle, Astronaut, Buzz Aldrin, Cape Canaveral Air Force Station, Edwin Eugene Aldrin Jr, Final Flight, Gemini 12, Gemini Launch Vehicle, Gemini XII, GLV-12, ICBM, Intercontinental Ballistic Missile, James A. Lovell Jr., Jim Lovell, Kennedy Space Center, Launch Complex 14, Launch Complex 19, Liquid-Fueled Rocket, Manned Space Flight, Martin Marierra Corporation, McDonnell Aircraft Corporation, NASA, Project Gemini, Target Launch Vehicle (TLV 5307), Titan II GLV, Two-Stage RocketBryan Swopes

Gemini XII lifts off from LC-19 at 2:21:04 p.m., EST, 11 November 1966. (NASA) — Gemini XII lifts off from LC-19 at 3:46:33 p.m., EST, 11 November 1966. (NASA)

11 November 1966: Gemini 12 lifted off from Launch Complex 19 at the Cape Canaveral Air Force Station, Florida, at 3:36.33.419 p.m., Eastern Standard Time. Two NASA Astronauts, Captain James A Lovell, Jr., United States Navy, and Major Edwin E. (“Buzz”) Aldrin, Jr., United States Air Force, were the crew. This was the second space flight for Lovell, who had previously flown on Gemini VII, and would later serve as Command Module Pilot on Apollo 8 and Mission Commander on Apollo 13. It was Aldrin’s first space flight. He would later be the Lunar Module Pilot of Apollo 11, and was the second human to set foot of the surface of the Moon.

The Gemini 12 mission was to rendezvous and docking with an Agena Target Vehicle, which had been launched from Launch Complex 14, 1 hour, 38 minutes, 34.731 seconds earlier by an Atlas Standard Launch Vehicle (SLV-3), and placed in a nearly circular orbit with a perigee of 163 nautical miles (187.6 statute miles/301.9 kilometers) and apogee of 156 nautical miles (179.5 statute miles/288.9 kilometers).

Artist’s concept of Gemini spacecraft, 3 January 1962. (NASA-S-65-893)

The two-man Gemini spacecraft was built by the McDonnell Aircraft Corporation of St. Louis, the same company that built the earlier Mercury space capsule. The spacecraft consisted of a reentry module and an adapter section. It had an overall length of 19 feet (5.791 meters) and a diameter of 10 feet (3.048 meters) at the base of the adapter section. The reentry module was 11 feet (3.353 meters) long with a diameter of 7.5 feet (2.347 meters). The weight of the Gemini varied from ship to ship, but Spacecraft 12 weighed 8,296.47 pounds (3,763.22 kilograms) at liftoff.

The Titan II GLV was a “man-rated” variant of the Martin SM-68B intercontinental ballistic missile. It was assembled at Martin Marietta’s Middle River, Maryland plant so as not to interfere with the production of the ICBM at Denver, Colorado. Twelve GLVs were ordered by the Air Force for the Gemini Program.

The Titan II GLV was a two-stage, liquid-fueled rocket. The first stage was 63 feet (19.202 meters) long with a diameter of 10 feet (3.048 meters). The second stage was 27 feet (8.230 meters) long, with the same diameter. The 1st stage was powered by an Aerojet Engineering Corporation LR-87-7 engine which combined two combustion chambers and exhaust nozzles with a single turbopump unit. The engine was fueled by a hypergolic combination of hydrazine and nitrogen tetroxide. Ignition occurred spontaneously as the two components were combined in the combustion chambers. The LR-87-7 produced 430,000 pounds of thrust (1,912.74 kilonewtons).¹ It was not throttled and could not be shut down and restarted. The 2nd stage used an Aerojet LR-91 engine which produced 100,000 pounds of thrust (444.82 kilonewtons).²

The Gemini/Titan II GLV combination had a total height of 109 feet (33.223 meters) and weighed approximately 340,000 pounds (154,220 kilograms) when fueled.³

Astronaut Buzz Aldrin standing in the open hatch of Gemini XII in Earth orbit. (NASA)

Gemini XII was the tenth and last flight of the Gemini program. The purpose of this mission was to test rendezvous and docking with an orbiting Agena Target Docking Vehicle and to test extravehicular activity (“EVA,” or “space walk”) procedures. Both of these were crucial parts of the upcoming Apollo program and previous problems would have to be resolved before the manned space flight projects could move to the next phase.

Buzz Aldrin had made a special study of EVA factors, and his three “space walks,” totaling 5 hours, 30 minutes, were highly successful. The rendezvous and docking was flown manually because of a computer problem, but was successful. In addition to these primary objectives, a number of scientific experiments were performed by the two astronauts.

Gemini XII is tethered to the Agena TDV, in Earth orbit over the southwest United States and northern Mexico. (NASA)

Gemini XII reentered Earth’s atmosphere and splashed down in the Atlantic Ocean, just 3.8 nautical miles (4.4 statute miles/7.0 kilometers) from the planned target point. Lovell and Aldrin were hoisted aboard a Sikorsky SH-3A Sea King helicopter and transported to the primary recovery ship, USS Wasp (CVS-18). The total duration of the flight was 3 days, 22 hours, 34 minutes, 31 seconds.

Gemini 12 splashes down in the Atlantic Ocean. (NASA S66-59936)

Gemini XII astronauts Major Edwin E. Aldrin, Jr., USAF, and Captain James A. Lovell, Jr., USN, arrive aboard USS Wasp (CVS-18), 15 November 1966. (NASA)

¹ Post-flight analysis gave the total average thrust of GLV-12’s first stage as 458,905 pounds of thrust (2,041.31 kilonewtons)

² Post-flight analysis gave the total average thrust of GLV-12’s second stage as 99,296 pounds of thrust (441.69 kilonewtons)

³ Gemini XII/Titan II GLV (GLV-12) weighed 345,710 pounds (156,811 kilograms) at Stage I ignition.

9 November 1967, 12:00:01.263 UTC, T plus 0.263

November 9, 2024Space FlightApollo 4, Apollo Program, Apollo Spacecraft 017, AS-501, Boeing, Douglas Aircraft Company, Kennedy Space Center, Launch Complex 39A, Liquid-Fueled Rocket, Lunar Module Test Article LTA-10R, Manned Space Flight, Multi-Stage Rocket, North American Aviation Inc., Rocket, Rocketdyne Division of North American Aviation Inc., Rocketdyne F-1, Rocketdyne J-2, S-IC, S-II, S-IVB, Saturn, Saturn Launch Vehicle SA-501, Saturn VBryan Swopes

Apollo 4 Saturn V (AS-501) on the launch pad at sunset, the evening before launch, 8 November 1967. (NASA)

9 November 1967: The first flight of a Saturn V took place when the unmanned Apollo 4/Saturn V (AS-501) was launched from Pad 39A at the Kennedy Space Center, Cape Canaveral, Florida. The rocket lifted off at 12:00:01.263 UTC.

AS-501 consisted of the first Saturn V launch vehicle, SA-501, with Apollo Spacecraft 017 (a Block I vehicle with Block II upgrades), and included the Launch Escape Tower, Command Module, Service Module, Lunar Module Adapter, and Lunar Module Test Article LTA-10R).

The Saturn V rocket was a three-stage, liquid-fueled heavy launch vehicle. Fully assembled with the Apollo Command and Service Module, it stood 363 feet, 0.15 inches (110.64621 meters) tall, from the tip of the escape tower to the bottom of the F-1 engines. The first and second stages were 33 feet, 1.2 inches (10.089 meters) in diameter. Fully loaded and fueled the rocket weighed 6,200,000 pounds (2,948,350 kilograms).¹ It could lift a payload of 260,000 pounds (117,934 kilograms) to Low Earth Orbit.

The first stage was designated S-IC. It was designed to lift the entire rocket to an altitude of 220,000 feet (67,056 meters) and accelerate to a speed of more than 5,100 miles per hour (8,280 kilometers per hour). The S-IC stage was built by Boeing at the Michoud Assembly Facility, New Orleans, Louisiana. It was 138 feet (42.062 meters) tall and had an empty weight of 290,000 pounds (131,542 kilograms). Fully fueled with 203,400 gallons (770,000 liters) of RP-1 and 318,065 gallons (1,204,000 liters) of liquid oxygen, the stage weighed 5,100,000 pounds (2,131,322 kilograms). It was propelled by five Rocketdyne F-1 engines, producing 1,522,000 pounds of thrust, each, for a total of 7,610,000 pounds of thrust at Sea Level.² These engines were ignited seven seconds prior to lift off and the outer four burned for 168 seconds. The center engine was shut down after 142 seconds to reduce the rate of acceleration. The F-1 engines were built by the Rocketdyne Division of North American Aviation at Canoga Park, California.

A Rocketdyne F-1 engine is being installed on a Saturn S-IC first stage. (NASA)

The S-II second stage was built by North American Aviation at Seal Beach, California. It was 81 feet, 7 inches (24.87 meters) tall and had the same diameter as the first stage. The second stage weighed 80,000 pounds (36,000 kilograms) empty and 1,060,000 pounds loaded. The propellant for the S-II was liquid hydrogen and liquid oxygen. The stage was powered by five Rocketdyne J-2 engines, also built at Canoga Park. Each engine produced 232,250 pounds of thrust, and combined, 1,161,250 pounds of thrust.³

The Saturn V third stage was designated S-IVB. It was built by Douglas Aircraft Company at Huntington Beach, California. The S-IVB was 58 feet, 7 inches (17.86 meters) tall with a diameter of 21 feet, 8 inches (6.604 meters). It had a dry weight of 23,000 pounds (10,000 kilograms) and fully fueled weighed 262,000 pounds. The third stage had one J-2 engine and also used liquid hydrogen and liquid oxygen for propellant.⁴ The S-IVB would place the Command and Service Module into Low Earth Orbit, then, when all was ready, the J-2 would be restarted for the Trans Lunar Injection.

Eighteen Saturn V rockets were built. They were the most powerful machines ever built by man.

Apollo 4 Saturn V AS-501 lifts off at 12:00:01 UTC, 9 November 1967. (NASA) — Apollo 4 Saturn V (AS-501) lifts off at 12:00:01 UTC, 9 November 1967. (NASA)

¹ The AS-501 total vehicle mass at First Motion was 6,137,868 pounds (2,784,090 kilograms).

² Post-flight analysis gave the total thrust of AS-501’s S-IC stage as 7,728,734.5 pounds of thrust (34,379.1 kilonewtons).

³ Post-flight analysis gave the total thrust of AS-501’s S-II stage as 1,086,396 pounds of thrust (4,832.5 kilonewtons).

⁴ Post-flight analysis gave the total thrust of AS-501’s S-IVB stage as 222,384 pounds of thrust (989.2 kilonewtons) during the first burn; 224,001 pounds (996.4 kilonewtons) during the second burn.

29 October 1998

October 29, 2024Space FlightAstronaut, Fighter Pilot, John Glenn, John Herschel Glenn Jr., Manned Space Flight, Space Shuttle Discovery (OV-103), Space Shuttle Program, STS-95, Test Pilot, United States SenatorBryan Swopes

Senator John H. Glenn, Jr., 1998. (NASA)

29 October 1998: Senator John Herschel Glenn, Jr., the first American to orbit the Earth, returned to space as a member of the Discovery STS-95 crew. At the age of 77, John Glenn was the oldest human to fly into space.

The STS-95 mission elapsed time was 8 days, 21 hours, 44 minutes, 2 seconds. Combined with Senator Glenn’s orbital flight of 20 February 1961 aboard the Mercury space vehicle, Friendship 7, his total space mission time is 9 days, 2 hours, 39 minutes, 49 seconds. He has completed 137 orbits of the Earth.

Space Shuttle *Discovery* (STS-95) launches at Launch Complex 39B, Kennedy Space Center, Cape Canaveral, Florida, 2:19:34 p.m., EST, 29 October 1998. This was *Discovery*‘s 25th flight. (NASA)

22 October 1968, 11:11:48 UTC

October 22, 2024AviationApollo 7, Apollo Program, AS-205, CSM-101, Donn F. Eisele, Manned Space Flight, R. Walter Cunningham, Saturn IB, USS Essex (CVS-9), Walter M. SchirraBryan Swopes

The Apollo 7 command module descends to the surface of the Atlantic Ocean under three parachutes, 22 October 1968. (NASA)

22 October 1968, 11:11:48 UTC: The first manned mission of the Apollo Program, Apollo 7, “splashed down” in the North Atlantic Ocean. The three man crew, Walter M. Schirra, Donn F. Eisele, and R. Walter Cunningham, had completed 163 orbits in 10 days, 20 hours, 9 minutes, 3 seconds. The spacecraft landed 7 nautical miles (13 kilometers) from the recovery ship, USS Essex (CVS-9).

The crew of Apollo 7 on the flight deck of USS Essex (CVS-9), 22 October 1968. Left to right, Captain Walter M. Schirra, USN; Major Donn F. Eisele, USAF; Major R. Walter Cunningham, USMC. (NASA)

11 October 1968, 15:02:45 UTC, T plus 000:00:00.36

October 11, 2024AviationAerojet AJ10-137, Aerojet General Corporation, Apollo 7, Apollo 7 Saturn IB (AS-205), Apollo Program, AS-205, Astronauts, Cape Kennedy Air Force Station, CSM-101, Donn F. Eisele, Manned Space Flight, R. Walter Cunningham, Rocketdyne Division of North American Aviation Inc., Rocketdyne H-1, Rocketdyne J-2, Saturn IB SA-205, USS Essex (CVS-9), Wally Schirra, Walter M. SchirraBryan Swopes

Apollo 7 Saturn 1B (AS-205) lifts off from Launch Complex 34 at the Kennedy Space Center, 15:02:45 UTC, 11 October 1968. (NASA) — Apollo 7 Saturn 1B (AS-205) lifts off from Launch Complex 34, Cape Kennedy Air Force Station, 15:02:45 UTC, 11 October 1968. (NASA)

11 October 1968: at 15:02:45 UTC, Apollo 7, the first manned Apollo spacecraft, was launched aboard a Saturn IB rocket from Launch Complex 34, Cape Kennedy Air Force Station, Cape Kennedy, Florida.

The flight crew were Captain Walter M. (“Wally”) Schirra, United States Navy, the mission commander, on his third space flight; Major Donn F. Eisele, U.S. Air Force, the Command Module Pilot, on his first space flight; and Major R. Walter Cunningham, U.S. Marine Corps, Lunar Module Pilot, also on his first space flight.

The flight crew of Apollo 7, left to right: Donn Eisele, USAF, Capain Walter M. ("Wally") Schirra, USN, and Major R. Walter Cunningham, USMC. (NASA) — The flight crew of Apollo 7, left to right: Major Donn F. Eisele, USAF, Captain Walter M. (“Wally”) Schirra, USN, and Major R. Walter Cunningham, USMCR. (NASA)

The mission was designed to test the Apollo spacecraft and its systems. A primary goal was the test of the Service Propulsion System (SPS), which included a restartable Aerojet AJ10-137 rocket engine which would place an Apollo Command and Service Module into and out of lunar orbit on upcoming missions.

The SPS engine was built by Aerojet General Corporation, Azusa, California. It burned a hypergolic fuel combination of Aerozine 50 (a variant of hydrazine) and nitrogen tetraoxide, producing 20,500 pounds of thrust. It was designed for a 750 second duration, or 50 restarts during a flight. This engine was fired eight times and operated perfectly.

The duration of the flight of Apollo 7 was 10 days, 20 hours, 9 minutes, 3 seconds, during which it orbited the Earth 163 times. The spacecraft splashed down 22 October 1968, approximately 230 miles (370 kilometers) south south west of Bermuda in the Atlantic Ocean, 8 miles (13 kilometers) from the recovery ship, the aircraft carrier USS Essex (CVS-9).

The Apollo command module was a conical space capsule designed and built by North American Aviation to carry a crew of three on space missions of two weeks or longer. Apollo 7 (CSM-101) was the first Block II capsule, which had been extensively redesigned following the Apollo 1 fire which had resulted in the deaths of three astronauts. The Block II capsule was 10 feet, 7 inches (3.226 meters) tall and 12 feet, 10 inches (3.912 meters) in diameter. It weighed 12,250 pounds (5,557 kilograms). There was 218 cubic feet (6.17 cubic meters) of livable space inside.

Apollo 7/Saturn IB AS-205.at Launch Complex 34.(NASA)

The Saturn IB consisted of an S-IB first stage and an S-IVB second stage. The S-IB was built by Chrysler. It was powered by eight Rocketdyne H-1 engines, burning RP-1 and liquid oxygen. Eight Redstone rocket fuel tanks containing the RP-1 fuel surrounded a Jupiter rocket tank containing the liquid oxygen. Total thrust of the S-IB stage was 1,600,000 pounds and it carried sufficient propellant for 150 seconds of burn. This would lift the vehicle to an altitude of 37 nautical miles (69 kilometers).

The Douglas-built S-IVB stage was powered by one Rocketdyne J-2 engine, fueled by liquid hydrogen and liquid oxygen. The single engine produced 200,000 pounds of thrust and had enough fuel for 480 seconds of burn.

The Saturn IB rocket stood 141 feet, 6 inches (43.13 meters) without payload. It was capable of launching a 46,000 pound (20,865 kilogram) payload to Earth orbit.