Tag Archives: Marion E. Carl

25 August 1947

Major Marion E. Carl, USN, with a Douglas D-558-I Skystreak at Muroc Dry Lake, 1947. (U.S. Navy)
Major Marion E. Carl, USMC, with a Douglas D-558-I Skystreak at Muroc Dry Lake, 1947. (U.S. Navy)

25 August 1947: Major Marion Eugene Carl, United States Marine Corps, flying the Douglas D-558-I Skystreak, Bu. No. 37970, set a new Fédération Aéronautique Internationale (FAI) World Record for Speed Over a 3 Kilometer Straight Course, averaging 1,047.356 kilometers per hour (650.797 miles per hour).¹ The Skystreak was flown over a course laid out on Muroc Dry Lake, site of Muroc Army Air Field (now Edwards Air Force Base) in the high desert of Southern California.

Douglas D-558-I Skystreak Bu. No. 37970 makes a pass over the 3 kilometer course on Muroc Dry Lake. (U.S. Navy)
Douglas D-558-I Skystreak Bu. No. 37970 makes a pass over the 3 kilometer course on Muroc Dry Lake. (U.S. Navy)

Four passes were made over the course at an altitude of 200 feet (61 meters) or lower. Two runs were made in each direction to compensate for any head or tail winds. The official speed for a record attempt was the average of the two best consecutive passes out of the four.

Major Carl’s record exceeded one set by Commander Turner F. Caldwell, Jr., U.S. Navy, just five days earlier by 10.053 miles per hour (16.178 kilometers per hour).

Major Marion E. Carl, USMC, and Commander Turner F. Caldwell, Jr., USN, stand with the record-setting Douglas D-558-I Skystreak, Bu. No. 37970, on Muroc Dry Lake. (U.S. Navy)
Major Marion E. Carl, USMC, and Commander Turner F. Caldwell, Jr., USN, stand with the record-setting Douglas D-558-I Skystreak, Bu. No. 37970, on Muroc Dry Lake. (U.S. Navy) 

The D-558 Program was intended as a three phase test program for the U.S. Navy and the National Advisory Committee on Aeronautics (NACA) to investigate transonic and supersonic flight using straight and swept wing aircraft powered by turbojet and/or rocket engines. The Douglas Aircraft Company designed and built three D-558-I Skystreaks and three D-558-II Skyrockets. The Phase I aircraft were flown by Douglas test pilot Eugene Francis (“Gene”) May, Navy Project Officer Commander Turner F. Caldwell, Jr., and Major Marion Carl.

Major Marion E. Carl, USMC; Gene May, Douglas Aircraft Company; Commander Turner F. Caldwell, USN.
Major Marion E. Carl, USMC; Gene May, Douglas Aircraft Company; Commander Turner F. Caldwell, USN.

The D-558-I Skystreak (also referred to as the D-558-1) was a single-engine, straight winged, turbojet-powered airplane. It was built of magnesium and aluminum for light weight, but was designed to withstand very high acceleration loads. It was 35 feet, 8 inches (10.871 meters) long with a wingspan of 25 feet, 0 inches (7.62 meters) and overall height of 12 feet, 1¾ inches (3.702 meters). The airplane had retractable tricycle landing gear. Its empty weight was approximately 7,500 pounds (3,400 kilograms), landing weight at the conclusion of a flight test was 7,711 pounds (3,498 kilograms). The maximum takeoff weight was 10,105 pounds (4,583.6 kilograms). The aircraft fuel load was 230 gallons (870.7 liters) of kerosene.

The D-558-I was powered by a single Allison J35-A-11 turbojet engine. The J35 was a single-spool, axial-flow turbojet with an 11-stage compressor section, 8 combustion chambers and single-stage turbine. The J35-A-11 was rated at 5,000 pounds of thrust (22.24 kilonewtons). The engine was 12 feet, 1.0 inches (3.683 meters) long, 3 feet, 4.0 inches (1.016 meters) in diameter and weighed 2,455 pounds (1,114 kilograms). The J35-A-11 was a production version of the General Electric TG-180, initially produced by Chevrolet as the J35-C-3. It was the first widely-used American jet engine.

The D-558-I had a designed service ceiling of 45,700 feet (13,930 meters). Intended for experimental flights of short duration, it had a very short range and took off and landed from the dry lake at Muroc. (After 1949, this would be known as Edwards Air Force Base.) The experimental airplane was not as fast as the more widely known Bell X-1 rocketplane, but rendered valuable research time in the high transonic range.

Gene May did reach Mach 1.0 in 37970, 29 September 1948, though he was in a 35° dive. This was the highest speed that had been reached up to that time by an airplane capable of taking off and landing under its own power.

The three D-558-I Skystreaks made a total of 229 flights and Bu. No. 37970 made 101 of them. After the Douglas test program was completed, -970 was turned over to NACA as NACA 140, but it was quickly grounded after the crash of the number two aircraft, and was used for spare parts for number three.

Today, 37970 is in the collection of the National Naval Aviation Museum at Naval Air Station Pensacola, Florida. The other surviving Skystreak, Bu. No. 37972, is at the Carolinas Aviation Museum, Charlotte-Douglas International Airport, Charlotte, North Carolina.

This painting depicts Major Marion E. Carl's speed record attempt over the 3 kilometer course at Muroc Dry Lake. (Steve Cox, 24" x 30", acrylic on board)
This painting depicts Major Marion E. Carl’s speed record attempt over the 3 kilometer course at Muroc Dry Lake. (Steve Cox, 24″ × 30″, acrylic on board)

¹ FAI Record File Number 9865

© 2017, Bryan R. Swopes

Facebooktwittergoogle_plusredditpinterestlinkedinmailby feather

21 August 1953

Douglas D-558-II Skyrocket, Bu. No., 37974, NACA 144, is dropped from the Boeing P2B-1S Superfortress, Bu. No. 84029, NACA 137. (NASA)
Douglas D-558-II Skyrocket, Bu. No., 37974, is dropped from the Boeing P2B-1S Superfortress, Bu. No. 84029. (NASA)

21 August 1953: Major Marion E. Carl, United States Marine Corps, flew the number three Douglas D-558-II Skyrocket, Bu. No. 37974, to an unofficial world altitude record of 83,235 feet (25,370 meters).

The supersonic research rocketplane had been dropped from a Boeing P2B-1S Superfortress at 30,000 feet (9,144 meters) over Edwards Air Force Base. During this flight the Skyrocket reached Mach 1.728.

The Associated Press wire service reported the event:

Altitude Record Set By Hubbard Pilot

     WASHINGTON (AP) —The Navy said Monday Lt. Col. Marion E. Carl, a Marine Corps pilot set a new altitude record of 83,235 feet in the Douglas Skyrocket research plane on Aug. 21.

    The Navy said the unofficial world mark was established during a test of a newly developed high-altitude flying suit. ¹

     The previous altitude record was 79,494 feet, set in the same airplane by Douglas test pilot Bill Bridgeman on Aug. 7, 1951.

     A Navy spokesman said Carl is at Edwards Air Force Base, Calif. for an attempt Monday or Tuesday on the speed mark of 1,238 miles an hour set by Bridgeman in the Navy D-558-2 Skyrocket Aug. 1, 1951.

     As in Bridgeman’s altitude and speed record flight, Carl’s runs are being made through aerial launching. The Skyrocket is carried to an altitude of 30,000 feet or better by a B29 “mother plane,” and then released.

     National Aeronautic Assn. rules require that altitude record attempts be launched from the ground and that speed runs be made at specified altitudes.

     For these reasons, none of the Skyrocket records is, or likely to become, official. Some flying authorities have urged that official rules be rewritten to conform to modern developments in flying technique.

     Carl is from Hubbard, Ore. and is stationed at the Quantico, Va., Marine Corps Air Station. He has been assigned as assistant Marine Corps project officer for the national aircraft show at Dayton next week.

     Five Years ago Carl set a world speed mark of 650.8 miles an hour in the Skyrocket’s Navy predecessor, the D-558-1 Skystreak.

Eugene Register-Guard, Vol. XXCVII, No. 243, 31 August 1951, at Page 1A, Columns 6 and 7

Screen Shot 2016-08-07 at 11.13.14

20 November 1953: At Edwards Air Force Base, California, NACA’s High Speed Flight Station test pilot Albert Scott Walker rode behind the flight crew of the Boeing P2B-1S Superfortress as it carried the Douglas Aircraft Company D-558-II Skyrocket supersonic research rocketplane to its launch altitude. As the four-engine bomber climbed through 18,000 feet (5,486 meters), Crossfield headed back to the bomb bay to enter the Skyrocket’s cockpit and prepare for his flight.

The Douglas D-558-II was Phase II of a U.S. Navy/Douglas Aircraft Company/National Advisory Committee on Aeronautics joint research project exploring supersonic flight. It was a swept-wing airplane powered by a single Reaction Motors LR8-RM-6 four-chamber rocket engine. The Skyrocket was fueled with alcohol and liquid oxygen. The engine was rated at 6,000 pounds of thrust (26.69 kilonewtons) at Sea Level.

There were three Phase II aircraft. Originally, they were also equipped with a Westinghouse J34-W-40 turbojet engine which produced 3,000 pounds of thrust (13.35 kilonewtons) and the Skyrockets took off from the surface of Rogers Dry Lake. Once the D-558-II reached altitude, the rocket engine was fired for the speed runs. As higher speeds were required, the program shifted to an air launch from a B-29 (P2B-1S) “mothership”. Without the need to climb to the test altitude, the Skyrocket’s fuel load was available for the high speed runs.

The D-558-II was 42.0 feet (12.80 meters) long, with a wingspan of 25.0 feet (7.62 meters). The leading edge of the wing was swept at a 35° angle and the tail surfaces were swept to 40°. The aircraft weighed 9,421 pounds (4,273 kilograms) empty and had a maximum takeoff weight of 15,787 pounds (7,161 kilograms). It carried 378 gallons (1,431 liters) of water/ethyl alcohol and 345 gallons (1,306 liters) of liquid oxygen.

The mothership, NACA 137, was a Boeing Wichita B-29-95-BW Superfortress, U.S. Air Force serial number 45-21787. It was transferred to the U.S. Navy, redesignated P2B-1S and assigned Bureau of Aeronautics number 84029. Douglas Aircraft modified the bomber for its drop ship role at the El Segundo plant.

Between 4 February 1948 and 28 August 1956, the three rocketplanes made a total of 313 flights.

Douglas D-558-2 Skyrocket, Bu. No. 37974. (NASA)
The rocket-powered Douglas D-558-2 Skyrocket, Bu. No. 37974 (NACA 144). (NASA)

Marion Eugene Carlwas born at Hubbard, Oregon, 1 November 1915. He was the second of four children of Herman Lee Carl, a dairy farmer, and Ellen Lavine Ellingsen Carl.

Marion E. Carl 1935

Carl graduated from Oregon State College at Corvallis, Oregon, and was commissioned as a second lieutenant in the United States Army Reserve, 31 May 1938. Lieutenant Carl soon resigned this commission to accept an appointment as an Aviation Cadet, United States Navy. He enlisted as a private, first class, Volunteer Marine Corps Reserve, 17 July 1938, and was designated a student Enlisted Naval Aviation Pilot assigned to the Naval Reserve Aviation Base, Squantum, Massachusetts. He entered flight school as an Aviation Cadet at Naval Air Station Pensacola near Pensacola, Florida, 26 July 1938.

Lieutenant Marion E. Carl, USMC, Naval Aviator. (U.S. Navy)

After completing flight training, Carl was commissioned as a Second Lieutenant, United States Marine Corps Reserve, 20 October 1939. He was then assigned to Marine Fighting Squadron One (VMF-1) at Brown Field, Quantico, Virginia.

In 1940, Lieutenant Carl returned to NAS Pensacola as a flight instructor. On 25 February 1941, Second Lieutenant Carl, U.S.M.C.R., was appointed a Second Lieutenant, United States Marine Corps.

Lieutenant Carl was transferred to VMF-221 at San Diego, California, as a fighter pilot. The unit was assigned to the aircraft carrier USS Saratoga (CV-3) for transportation to MCAS Ewa, Oahu, Territory of Hawaii. On 25 December 1941, VMF-221 was deployed to Midway Atoll.

Marion Carl and his squadron fought during the Battle of Midway. Flying a Grumman F4F-3 Wildcat, Bu. No. 1864,² on 4 June 1942, he shot down his first enemy airplane, a Mitsubishi A6M Zero fighter, and damaged two others. Lieutenant Carl was awarded the Navy Cross for his actions in that decisive battle.

Marion Carl was next assigned to VMF-223 under the command of Captain John L. Smith. The Marine fighter squadron was the first air unit to arrive at Henderson Field on the island of Guadalcanal in the Solomons, 20 August 1942. This was a critical airfield, originally built by the Japanese military but occupied by Allied forces. On 26 August, Lieutenant Carl became the Marine Corps’ first “ace.”

Carl was shot down in 9 September 1942 and was missing for five days. He was helped by islanders who eventually returned him to his base.

The squadron departed Guadalcanal 16 October 1942, and sailed to San Francisco, California. VMF-223 was credited with destroying 110½ enemy aircraft. Carl was credited with 16.

Lieutenant Carl married Miss Edna T. Kirvin at New York City, New York, 7 January 1943.

On 26 January, he took command of VMF-223. On 8 May 1943, Lieutenant Carl was promoted to the temporary rank of captain. The squadron was re-equipped with the new Vought-Sikorsky F4U-1 Corsair. Training in the new fighter took place at MCAS El Toro, in southern California.

Major Marion E. Carl, USMC, commanding VMF-223 in 1943. The aircraft is a Vought F4U Corsair in which Carl shot down two enemy aircraft in December 1943. (U.S. Navy)

In August, the squadron returned to combat in the Solomons. By the end of 1943, Major Carl’s total of enemy aircraft destroyed was 18½ with 3 damaged, making him the seventh highest-scoring Marine fighter pilot of World War II.

Marion Carl is dressing in teh Model 7 pressure suit aboard the P2BS-1 drop ship, 21 August 1953. (U.S. Navy)
Marion Carl is dressing in the David Clark Company Model 7 full-pressure suit aboard the P2B-1S drop ship, 21 August 1953. (U.S. Navy)

After the War Marion Carl trained as a test pilot at NAS Patuxent River, Maryland, testing jet aircraft on aircraft carriers and he was also the first Marine Corps pilot to fly a helicopter. He commanded the Marine’s first jet squadron, VMF-122, which flew the McDonnell FH-1 Phantom. He was promoted to lieutenant colonel 7 August 1947.

In May 1955, Colonel Carl commanded Marine Photo Reconnaisance Squadron One (VMJ-1). The squadron flew the McDonnell FH-2 Banshee from air bases on Taiwan on secret missions over the People’s Republic of China.

At Muroc Army Air Field (now Edwards Air Force Base) he tested the Douglas D-558-I Skystreak and D-558-II Skyrocket, setting world records for speed and altitude. He was promoted to colonel, 1 October 1956.

By 1962 Colonel Carl was Director of Marine Corps Aviation. He was promoted to brigadier general, 1 June 1964.

Brigadier General Carl commanded the First Marine Brigade during the Vietnam War and flew combat missions in jet fighters and helicopter gun ships.

Promoted to major general in August 1967, with his date of rank retroactive to 1 June 1964. Carl commanded the 2nd Marine Aircraft Wing, then served as Inspector General of the Marine Corps from 1970 until 1973. When he retired in 1973, General Carl had accumulated more that 13,000 flight hours.

During his military career, Major General Carl was awarded the Navy Cross with two gold stars (three awards); The Legion of Merit with valor device and three gold stars (four awards); The Distinguished Flying Cross with four gold stars (five awards); and the Air Medal with two gold and two silver stars (twelve awards).

Tragically, General Carl was murdered in Roseburg, Oregon, 28 June 1998, as he defended his wife, Edna, during a home-invasion robbery. Mrs. Carl was wounded, but survived.

Major General Marion E. Carl, United States Marine Corps, is buried at Arlington National Cemetery.

Major General Marion E. Carl, United States Marine Corps (1915–1998)
Major General Marion E. Carl, United States Marine Corps (1915–1998)

¹ The pressure suit Lieutenant Colonel Carl was testing was a David Clark Co. Model 7 full-pressure suit.

² Often cited as Grumman F4F-3 Bu. No. 4000 (second bureau number series, 1935–1940) the entry in Carl’s certified pilot logbook for 4 June 1942 states the airplane he flew to shoot down the enemy fighter was F4F-3 Bu. No. 1864.

© 2017, Bryan R. Swopes

Facebooktwittergoogle_plusredditpinterestlinkedinmailby feather