Tag Archives: McDonnell Aircraft Corporation

20 February 1962, 14:47:39 UTC

February 20, 2025Space FlightAstronaut, Atlas LV-3B, Cape Canaveral Air Force Station, Convair Division of General Dynamics, John Glenn, John Herschel Glenn Jr., Launch Complex 14, Low Earth Orbit, Manned Space Flight, McDonnell Aircraft Corporation, Mercury-Atlas 6, NASA, Project Mercury, Rocketdyne Division of North American Aviation Inc., Spacecraft No. 13Bryan Swopes

Launch of Friendship 7 from Launch Complex 14, Kennedy Space Center, 14:47:39 UTC, 20 February 1962. (NASA)

20 February 1962: At 9:47:39 a.m., Eastern Standard Time, NASA’s Mercury-Atlas 6 lifted off from Launch Complex 14, Cape Canaveral Air Force Station, Cape Canaveral, Florida. This was the third launch of a manned Mercury spacecraft, and the first time that an Atlas rocket had been used.

Aboard the spacecraft was Lieutenant Colonel John Herschel Glenn, Jr., United States Marine Corps, an experienced fighter pilot and test pilot.

John Herschel Glenn, Jr., NASA Project Mercury Astronaut. (Ralph Morse/LIFE Magazine)

In his post-flight mission report, Glenn wrote,

When the countdown reached zero, I could feel the engines start. The spacecraft shook, not violently but very solidly. There was no doubt when lift off occurred, When the Atlas was released there was an immediate gentle surge to let you know you were on your way.

—Results of the First United States Orbital Space Flight (NASA-TM-108606), Manned Spacecraft Center, National Aeronautics and Space Administration, at Page 120, Column 1

2 minutes, 9.6 seconds after liftoff, the booster engines cut of and were jettisoned. 23 seconds later, the escape tower, no longer needed, was also jettisoned. The Atlas sustainer engine continued to burn until T+00:05:01.4. The spacecraft had now reached 17,544 miles per hour (28,234 kilometers per hour) and was in an elliptical orbit around the Earth. At T+00:05:03.6 the Mercury spacecraft separated from the Atlas booster. During the climb to orbit, John Glenn experienced a maximum acceleration of 7.7 gs.

Glenn’s orbit had an apogee of 162.2 statute miles (261 kilometers) and perigee of 100 miles (161 kilometers). The orbit was inclined 32.54° relative to Earth’s orbital plane. Friendship 7 completed an orbit every 88 minutes, 29 seconds.

Analysis showed that the Atlas had placed Friendship 7 in orbit at a velocity with 7 feet per second (2.1 meters per second) less than nominal. However, computer analysis showed that the orbital trajectory was good enough for nearly 100 orbits.

This photograph of Friendship 7’s cockpit was taken in orbit around the Earth, 20 February 1962. Astronaut John Glenn’s hands and legs are visible at the lower edge of the image. (Ohio State University)

During the 4 hour, 55 minute, 23 second flight, the Mercury capsule orbited the Earth three times. John Glenn was the first American astronaut to orbit the Earth. (Cosmonaut Yuri Gagarin had orbited the Earth 12 April 1961.)

Friendship 7 is hoisted aboard USS Noa (DD-841). (U.S. Navy)

After re-entry, the capsule parachuted into the Atlantic Ocean, only six miles from the recovery ship, USS Noa (DD-841).

Mercury spacecraft profile with dimensions. (NASA)

The Mercury spacecraft, Friendship 7, was built by McDonnell Aircraft Corporation, St. Louis, Missouri. It was the 13th Mercury capsule built. Designed to carry one pilot, it could be controlled in pitch, roll and yaw by steam thrusters fueled by hydrogen peroxide. The Mercury was 7 feet, 2.83 inches (2.206 meters) long, not including its retro rocket pack. The spacecraft was generally conical, and had a maximum diameter of 6 feet, 2.50 inches (1.885 meters). It weighed 2,700 pounds (1,224.7 kilograms) at launch.

Diagram of Atlas LV-3B (Space Launch Report)

The rocket, a “1-½ stage” liquid-fueled Atlas LV-3B, number 109-D, was built by the Convair Division of General Dynamics at San Diego, California. It was developed from a U.S. Air Force SM-65 Atlas D intercontinental ballistic missile, modified for use as a “man-rated” orbital launch vehicle.

The LV-3B was 65 feet (19.812 meters) long from the base to the Mercury adapter section, and the tank section is 10 feet (3.038 meters) in diameter. The complete Mercury-Atlas orbital launch vehicle is 93 feet (28.436 meters) tall, including the escape tower. When ready for launch it weighed approximately 260,000 pounds (118,000 kilograms) and could place a 3,000 pound (1,360 kilogram) payload into low Earth orbit.

The Atlas’ three engines were built by the Rocketdyne Division of North American Aviation, Inc., at Canoga Park, California. Two Rocketdyne LR89-NA-5 engines and one LR105-NA-5 produced 341,140 pounds (1,517.466 kilonewtons) of thrust. The rocket was fueled by a highly-refined kerosene, RP-1, with liquid oxygen as the oxidizer.

Friendship 7 is displayed at the Smithsonian National Air and Space Museum.

John Glenn's Mercury spacecraft, Friendship 7, on display at the Smithsonian Institution National Air and Space Museum. (Photo by Eric Long, National Air and Space Museum, Smithsonian Institution.) — John Glenn’s Mercury spacecraft, Friendship 7, on display at the Smithsonian Institution National Air and Space Museum. (Photo by Eric Long, National Air and Space Museum, Smithsonian Institution.)

24 January 1962

January 24, 2025Aviation149405, 149406, 62-12168, 62-12169, Fighter, George Laven, Gordon Graham, Interceptor, McDonnell Aircraft Corporation, McDonnell F-110A Spectre, McDonnell F-4C Phantom II, McDonnell F4H-1 Phantom II, Sandy McDonnell, Sanford N. McDonnellBryan Swopes

24 January 1962: The McDonnell Aircraft Corporation delivered the first F-110A Spectre to Colonel Gordon Graham and Colonel George Laven, United States Air Force, at the McDonnell plant at St. Louis, Missouri. The F-110A was soon redesignated as the F-4C Phantom II.

Two Phantoms were delivered to the Air Force for evaluation at Langley Field, Virginia. They were U.S. Navy F4H-1 Phantom IIs, Bureau of Aeronautics serial numbers 149405 and 149406. Initially the aircraft retained the Navy serial numbers but eventually were assigned Air Force numbers 62-12168 and 62-12169. The Air Force bailed them back to McDonnell to develop the YF-4C prototypes.

62-12169 (ex-Bu. No. 149406) was converted to a JF-4B (a special test aircraft). Operated by the McDonnell-Douglas Aircraft Center at Holloman Air Force Base, New Mexico, it suffered an engine explosion, 8 March 1967. McDonnell test pilot Charles (“Pete”) Garrison successfully ejected. The airplane crashed and was destroyed.

McDonnell Aircraft Corporation F-110A Spectre 149405. (McDonnell Aircraft Corporation)

U.S. Air Force F-110A Spectre with bomb load. — U.S. Air Force F-110A Spectre 149405 armed with AIM-101 Sparrow missiles and Mk.82 500-pound bombs. (McDonnell Aircraft Corporation)

U.S. Air Force F-110A Spectre 149405 armed with AIM-101 Sparrow missiles and Mk.82 500-pound bombs. (NARA)

McDonnell built 5,057 Phantom IIs. They served with the United States Navy and Marine Corps, the U.S. Air Force, and many allied nations. The last Phantom II, an F-4E, was completed 25 October 1979. The U.S. Air Force retired its last operational Phantoms from service 20 December 2004, 42 years, 10 months, 27 days after receiving the first F-110A.

McDonnell F-110A Spectre 149405 (F4H-1, F-4B-9i, and F-4C-15-MC 62-12168). — McDonnell F-110A Spectre 149405 (F4H-1, F-4B-9i-MC, and finally, F-4C-15-MC 62-12168). (McDonnell Aircraft Corporation)

McDonnell F-110A 149406 at Nellis Air Force Base, March 1962. (NARA)

McDonnell F-4C-15-MC Phantom IIs 149405 and 149406, circa 1963. (NARA)

McDonnell F-110A 149405 and 149406 in formation near Lambert Field, St. Louis, Missouri. (NARA)

8 January 1973

January 8, 2025Aviation65-0796, AIM-7 Sparrow, Air Combat, Crafty 01, F-4D-29-MC, Fighter, Fighter Pilot, Lawrence W. Kullman, McDonnell Aircraft Corporation, McDonnell F-4D Phantom II, Mikoyan-Gurevich MiG 21, Paul D. Howman, Red Crown, Silver Star, Weapons System OfficerBryan Swopes

McDonnell F-4D-29-MC Phantom II 65-0796 at Yokota AB, Japan, 1972. (U.S. Air Force)

8 January 1973: Captain Paul D. Howman and First Lieutenant Lawrence W. Kullman, 4th Tactical Fighter Squadron, 432d Tactical Reconnaissance Wing, flying McDonnell F-4D-29-MC Phantom II 65-0796, were leading a flight of two fighters on combat air patrol in Route Pack III. Their call sign was CRAFTY ONE. A U.S. Navy guided missile cruiser, call sign RED CROWN, was steaming in the Gulf of Tonkin off the coast of North Vietnam, providing radar coverage for the fighters.

The following is a recount of the last USAF MiG kill in Southeast Asia; it occurred on 8 January 1973.

Crafty, a flight of two F-4s from the 4th Tactical Fighter Squadron, was assigned a night MiGCAP mission in support of B-52 strikes. They ingressed North Vietnam through the “Gorilla’s Head” and established their CAP about 70 miles southwest of Hanoi. The pilot of Crafty One was Captain Paul D. Howman. His backseater was First Lieutenant Lawrence W. Kullman. The following is Captain Howman’s description of the kill.

Because of its advanced air search radars and digital computers, the nuclear-powered guided missile cruiser USS Long Beach (CGN-9) frequently served as RED CROWN. (U.S. Navy)

“About five minutes after arriving on station, we were advised by Red Crown that a MiG was airborne out of Phuc Yen and was heading southwest toward the inbound strike force. They vectored us northwest and told us he had leveled at 13,000 feet. Passing through [a heading of] north, we picked him up on radar at about 60 miles. We were able to follow him most of the way in as the range decreased. At about 30 miles, I called 02 and we jettisoned our centerline tanks.”

Crafty One and Two descended to 12,000 feet at 400 knots, still taking vectors. Red Crown turned them to a northeasterly heading. At 16 miles, Red Crown cleared Crafty to fire. Captain Howman’s account continues.

“At 10 miles I got a visual on an afterburner plume 20 degrees right and slightly high. I called him out to the backseater and put the pipper on him. At 6 miles Lt. Kullman got a good full-system radar lock-on. Range was about 4 miles and overtake 900+ knots when I squeezed the trigger. The missile came off, did a little roll to the left, and tracked toward the “burner plume.” It detonated 50 feet short of his tail.

“I squeezed another one off at 2 miles range. This one just pulled some lead, then went straight for the MiG. It hit him in the fuselage and the airplane exploded and broke into three big flaming pieces.”

"Craft 01", McDonnell F-4D-29-MC Phantom II 65-0796 on static display at William E. Dyess Elementary School, Abilene, Texas. (Abilene School District photo) — “Crafty 01”, McDonnell F-4D-29-MC Phantom II 65-0796 on static display at William E. Dyess Elementary School, Abilene, Texas. (Abilene School District photo)

After determining there were no more MiGs in the area, Crafty returned to orbit for their remaining CAP period. They returned to base without further incident.

— The Tale of Two Bridges ; and The Battle for the Skies Over North Vietnam, by Major A. J. C. Lavalle, USAF, editor, Office of Air Force History, Washington, D.C., 1985, Chapter VI at Page 187–188.

The MiG 21 that Howman and Kullman shot down was the last air-to-air victory by the United States Air Force during the Vietnam War. Both men were awarded the Silver Star.

Their airplane, 65-0796, served another seventeen years before being retired. Today, it is on display at William E. Dyess Elementary School, Abilene, Texas.

A Mikoyan Gurevich MiG-21 at the National Museum of the United States Air Force. (U.S. Air Force) — An Aero Vodochody-built MiG 21F-13 with the markings of the Vietnam Peoples’ Air Force at the National Museum of the United States Air Force, Wright-Patterson Air Force Base, Ohio. (U.S. Air Force)

2 January 1967

January 2, 2025Aviation63-7680, Ace, Aerial Combat, AIM-9B Sidewinder, Air-to-Air Missile, Charles C. Clifton, F-4C-21-MC, Fighter, Fighter Pilot, Keith Ferris, McDonnell Aircraft Corporation, McDonnell F-4C Phantom II, MiG Sweep, Mikoyan-Gurevich MiG 21, Mikoyan-Gurevich MiG 21PFL, Phantom II, Robin Olds, Vietnam WarBryan Swopes

“MiG Sweep,” by Keith Ferris. Colonel Robin Olds uses a Vector Roll to gain firing position on a MiG-21 fighter. “I got on top of him and half upside down, hung there, and waited for him to complete more of his turn. . . .”

2 January 1967: This painting, MiG Sweep, by aviation artist Keith Ferris, depicts “Olds 01” during OPERATION BOLO. The twin-engine all-weather jet fighter, a McDonnell F-4C -21-MC Phantom II, serial number 63-7680, was flown by Colonel Robin Olds, USAF, with First Lieutenant Charles C. Clifton, USAF, as the Weapons System Operator.

The Phantom is shown inverted as Colonel Olds maneuvers to fire an AIM-9B Sidewinder heat-seeking missile at a North Vietnamese Mikoyan-Gurevich MiG-21 over Hanoi. Robin Olds was the only U.S. Air Force ace with victories in both World War II and Vietnam.

Colonel Robin Olds, United States Air Force, Wing Commander, 8th Tactical Fighter Wing. (U.S. Air Force)

The area around Hanoi, North Vietnam, was the most heavily defended target area ever encountered by the United States Air Force. A combination of radar-directed anti-aircraft artillery, surface-to-air guided missiles, and fighter interceptors made every mission very dangerous. Republic F-105 Thunderchief fighter bombers were taking heavy losses to the Soviet-built Mikoyan-Gurevich MiG-21PFL fighters. When escorting F-4C Phantoms would try to engage the MiGs, they would return to their bases which were safe from attack under the American rules of engagement.

Colonel Robin Olds with Captain John (“J.B.”) Stone, 433rd Tactical Fighter Squadron, one of the planners of OPERATION BOLO. (U. S. Air Force)

OPERATION BOLO was a complex plan to lure the ground-controlled MiG 21s into an air battle by having the Phantoms simulate a Thunderchief attack. Colonel Olds led 48 McDonnell F-4Cs of the 8th and 366th Tactical Fighter Wings on the same type of attack that would have been used by the Thunderchiefs, but rather than carrying a full load of bombs, the F-4s were armed with AIM-7E Sparrow radar-guided missiles and AIM-9B Sidewinder heat-seeking missiles. (The F-4C was not armed with a gun.)

A Mikoyan Gurevich MiG-21PF at the National Museum of the United States Air Force. — An Aero Vodochody-built Mikoyan-Gurevich MiG-21F-13 with the markings of the Vietnam Peoples’ Air Force at the National Museum of the United States Air Force, Wright-Patterson Air Force Base, Ohio. (U.S. Air Force)

As the Mach 2+ MiG 21s started coming up through the clouds, their pilots quickly realized that instead of the vulnerable targets of F-105s on a bomb run, they were faced with air superiority fighters.

In the official after action report, Colonel Olds said,

At the onset of this battle, the MiGs popped up out of the clouds. Unfortunately, the first one to pop through came up at my 6 o’clock position. I think this was more by chance than by design. As it turned out, within the next few moments, many others popped out of the clouds in varying positions around the clock.

This one was just lucky. He was called out by the second flight that had entered the area, they were looking down on my flight and saw the MiG-21 appear. I broke left, turning just hard enough to throw off his deflection, waiting for my three and four men to slice in on him. At the same time I saw another MiG pop out of the clouds in a wide turn about my 11 o’clock position, a mile and a half away. I went after him and ignored the one behind me. I fired missiles at him just as he disappeared into the clouds.

I’d seen another pop out in my 10 o’clock position, going from my right to left; in other words, just about across the circle from me. When the first MiG I fired at disappeared, I slammed full afterburner and pulled in hard to gain position on this second MiG. I pulled the nose up high about 45 degrees, inside his circle. Mind you, he was turning around to the left so I pulled the nose up high and rolled to the right. This is known as a vector roll. I got on top of him and half upside down, hung there, and waited for him to complete more of his turn and I timed it so that as I continued to roll down behind him, I’d be about 20 degrees angle off and about 4,500 to 5,000 feet behind him. That’s exactly what happened. Frankly, I’m not sure he ever saw me. When I got down low and behind, and he was outlined by the sun against a brilliant blue sky, I let him have two Sidewinders, one of which hit and blew his right wing off.

—Aces and Aerial Victories: The United States Air Force in Southeast Asia 1965–1973, by R. Frank Futrell, William H. Greenhalgh, Carl Grubb, Gerard E. Hasselwander, Robert F. Jakob and Charles A. Ravenstein, Office of Air Force History, Headquarters USAF, 1976, Chapter II at Page 39.

The F-4Cs succeeded in shooting down seven MiG 21s, with another two probably destroyed. This accounted for about half of the VPAF’s MiG 21 complement.

With another flight crew, the Phantom flown by Robin Olds on 2 January 1967, McDonnell F-4C-21-MC 63-7680, shot down a MiG 17 on 13 May 1967. It was itself shot down by antiaircraft fire while attacking a SAM site, 20 November 1967. The Weapons System Officer, 1st Lieutenant James L. Badley, bailed out and was rescued, but the pilot, Captain John M. Martin, was not seen to leave the aircraft and is listed as Missing in Action.

Colonel Robin Olds shot down two MiG-17 fighters with this McDonnell F-4C-21-MC Phantom II, 63-7680. (U.S. Air Force) — Colonel Robin Olds shot down a MiG 21 interceptor with this McDonnell F-4C-21-MC Phantom II, 63-7680, photographed at Ubon RTAFB, sometime between March and November 1967. (Photograph by Frank R. MacSorley, Jr.)

15 December 1965

December 15, 2024Space FlightAerojet Engineering Corporation, Frank F. Borman II, Gemini 6A, Gemini 7, James A. Lovell Jr., Manned Space Flight, Martin Marietta Corporation, Martin SLV-4 Titan II, McDonnell Aircraft Corporation, Orbital Rendezvous, Project Gemini, Thomas P. Stafford, Titan II GLV, Walter M. Schirra Jr.Bryan Swopes

15 December 1965: At 13:37:26 UTC, Gemini 6A, with NASA astronauts Captain Walter M. Schirra, Jr., United States Navy and Major Thomas P. Stafford, United States Air Force, on board, lifted off from Launch Complex 19 at the Cape Kennedy Air Force Station, Cape Kennedy, Florida. During its fourth orbit, Gemini 6A rendezvoused with Gemini 7, carrying Major Frank F. Borman II, USAF, and LCDR James A. Lovell, Jr., USN.

This was the first time that two manned space vehicles had rendezvoused in Earth orbit.

The two spacecraft remained together for 5 hours, 19 minutes before separating to a distance of approximately 10 miles (16 kilometers).

Gemini 7 had been in orbit since 4 December. Gemini 6, then 6A, had been postponed several times before finally launching on 15 December. It would return to Earth the following day, landing in the North Atlantic Ocean. Gemini 7 remained in orbit until 18 December.

The two-man Gemini spacecraft was built by the McDonnell Aircraft Corporation of St. Louis, Missouri, the same company that built the earlier Mercury space capsule. The spacecraft consisted of a series of cone-shaped segments forming a reentry module and an adapter section. It had an overall length of 18 feet, 9.84 inches (5.736 meters) and a maximum diameter of 10 feet, 0.00 inches (3.048 meters) at the base of the equipment section. The reentry module was 11 feet (3.353 meters) long with a maximum diameter of 7 feet, 6.00 inches (2.347 meters). The Gemini re-entry heat shield was a spherical section with a radius of 12 feet, 0.00 inches (3.658 meters). The weight of the Gemini spacecraft varied from ship to ship. Gemini VII had a gross weight of 8,076.10 pounds (3,663.26 kilograms) at launch. It was shipped from St. Louis to Cape Kennedy in early October 1965.

The Titan II GLV was a “man-rated” variant of the Martin Marietta Corporation SM-68B intercontinental ballistic missile. It was assembled at Martin’s Middle River, Maryland, plant so as not to interfere with the production of the ICBM at Denver, Colorado. Twelve GLVs were ordered by the Air Force for the Gemini Program. The GLV-7 first and second stages were shipped from Middle River to Cape Kennedy on 9 October 1965.

The Titan II GLV was a two-stage, liquid-fueled rocket. The first stage was 70 feet, 2.31 inches (21.395 meters) long with a diameter of 10 feet (3.048 meters). It was powered by an Aerojet Engineering Corporation LR87-7 engine which combined two combustion chambers and exhaust nozzles with a single turbopump unit. The engine was fueled by Aerozine 50, a hypergolic 51/47/2 blend of hydrazine, unsymetrical-dimethyl hydrazine, and water. Ignition occurred spontaneously as the components were combined in the combustion chambers. The LR87-7 produced approximately 430,000 pounds of thrust (1,912.74 kilonewtons). It was not throttled and could not be shut down and restarted. Post flight analysis indicated that the first stage engine of GLV-7 had produced an average of 462,433 pounds of thrust (2,057.0 kilonewtons). The second stage was 25 feet, 6.375 inches (7.031 meters) long, with the same diameter, and used an Aerojet LR91 engine which produced approximately 100,000 pounds of thrust (444.82 kilonewtons), also burning Aerozine 50. GLV-7’s LR91 produced an average of 102,584 pounds of thrust (456.3 kilonewtons).

The Gemini/Titan II GLV-7 combination had a total height of 107 feet, 7.33 inches (32.795 meters) and weighed 346,228 pounds (157,046 kilograms) at ignition.

This Day in Aviation

Important Dates in Aviation History