Tag Archives: North American Aviation X-15A-2

9 November 1962

Aviation, Space Flight, , , , , , , , , , , , , , , , ,

McKAY, John B. (Jack) with X-15 56-6672, 13 March 19649 November 1962: Flight 74 of the X-15 Program was the Number Two aircraft’s 31st flight. X-15 56-6671 was carried aloft by Balls 8, the Boeing NB-52B Stratofortress, 53-008, for launch over Mud Lake, Nevada. NASA test pilot John Barron (“Jack”) McKay was to take the rocketplane to 125,000 feet at Mach 5.5 to investigate the stability and handling of the X-15 with the lower half of the ventral fin removed, and to investigate aerodynamic boundary layer phenomena.

North American Aviation X-15 56-6671 under the right wing of a B-52 Stratofortress at 45,000 feet. (NASA)
North American Aviation X-15 56-6671 under the right wing of a B-52 Stratofortress at 45,000 feet. (NASA)

The B-52 mothership dropped Jack McKay and the X-15 right on schedule at 10:23:07.0 a.m., local time, from an altitude of 45,000 feet (13,716 meters) and speed of approximately 450 knots (833 kilometers per hour). McKay advanced the throttle to ignite the Reaction Motors XLR99-RM-1 rocket engine. It fired immediately but when McKay advanced the throttle for the full 57,000 pounds of thrust, the engine remained at just 30%.

The X-15 could have flown back to Edwards Air Force Base, about 200 miles (320 kilometers) to the south, but with the engine not responding to the throttle, it was uncertain that it would continue running. The decision was made to make an emergency landing at Mud Lake.

Having reached a peak altitude of 53,950 feet (16,444 meters) and Mach 1.49 (1,109 miles per hour/1,785 kilometers per hour), Jack McKay continued to circle the lake burning off propellants as he lost altitude. The engine was shut down at 70.5 seconds. McKay positioned the aircraft for landing as he continued to dump unused propellant and liquid oxygen, but a considerable amount remained on board.

As he neared touchdown, he tried to lower the flaps but they did not deploy. The X-15 touched down on the dry lake bed at 296 miles per hour (476.4 kilometers per hour), 66 miles per hour (106 kilometers per hour) faster than normal.

Duration of the flight from air launch to touchdown was 6 minutes, 31.1 seconds.

The high speed and extra weight caused the X-15’s rear skids to hit harder than normal. When the nose wheels hit, a rebound effect placed even higher loads on the rear struts. At the same time, with the elevators in an extreme nose-up position, the higher aerodynamic loads pushed the skids deeper into the lake bed. This higher loading caused the left rear strut to collapse. The X-15 rolled to the left and the left elevator dug into the lake bed. This caused the aircraft to start sliding to the left. Jack McKay jettisoned the canopy and as the right wing tip dug into the surface, the X-15 flipped over and came to rest upside down.

A Piasecki H-21 rescue helicopter lands near the overturned X-15 at Mud Lake, 9 November 1961. (NASA)
A Piasecki H-21 rescue helicopter lands near the overturned X-15 at Mud Lake, 9 November 1961. (NASA)
The X-15 rolled over when the left landing skid collapsed because of the high-speed, overweight emergency landing at Mud Lake, Nevada. Jack McKay was trapped in the cockpit and suffered serious spinal injuries. (NASA)
The X-15 rolled over when the left landing skid collapsed because of the high-speed, overweight emergency landing at Mud Lake, Nevada. Jack McKay was trapped in the cockpit and suffered serious spinal injuries. (NASA)
The Number Two X-15, 56-6671, lies upside down and severely damaged at Mud Lake, Nevada, 9 November 1962. (NASA)
The Number Two X-15, 56-6671, lies upside down and severely damaged at Mud Lake, Nevada, 9 November 1962. (NASA)

McKay was seriously injured. He was trapped in the upside down X-15 and was in danger from the vapors of the ammonia propellants and liquid oxygen. An H-21 rescue helicopter hovered overhead to blow the vapor away.

Prior to the flight, an Air Force C-130 had brought a fire engine and crew to standby at Mud Lake, returned to Edwards and picked up a second fire engine and its crew, then remained airborne should an emergency landing be made at another intermediate dry lake.

These propositioned emergency assets were able to rescue McKay and to transport him to the hospital back at Edwards.

McKay eventually recovered sufficiently to return to flight status, but ultimately his injuries forced him to retire.

The Number Two X-15 was severely damaged. It was taken back to North American and was rebuilt into the X-15A-2, intended to reach speeds up to Mach 8. It would be more than a year and a half before it flew again.

North American Aviation X-15A-2 56-6671, after a 19-month repair, redesign and modification program. The fuselage was lengthened, additional propellant and reaction control tanks installed internally, the nose wheel and rear landing skid struts lengthened, and external tanks installed. (NASA)
North American Aviation X-15A-2 56-6671, after a 19-month repair, redesign and modification program. The fuselage was lengthened, additional propellant and reaction control tanks installed internally, the nose wheel and rear landing skid struts lengthened, and external tanks installed. (NASA)

© 2016, Bryan R. Swopes

3 November 1965

Aviation, Space Flight, , , , , , , , , , , , , , ,
North American Aviation X-15A-2 56-6671 on Rogers Dry Lake. In addition to the lengthened fuselage and external tanks, the nose wheel strut is longer and the windshields have been changed to an oval shape. A wheeled dolly supports the aft end of the rocketplane. (NASA)
North American Aviation X-15A-2 56-6671 on Rogers Dry Lake. In addition to the lengthened fuselage and external tanks, the nose wheel strut is longer and the windshields have been changed to an oval shape. A wheeled dolly supports the aft end of the rocketplane. (NASA)

3 November 1965: Major Robert A. Rushworth made the first flight of the modified X-15A-2 rocketplane, Air Force serial number 56-6671. After a landing accident which caused significant damage to the Number 2 X-15, it was rebuilt by North American Aviation. A 28-inch (0.71 meter) “plug” was installed in the fuselage forward of the wings to create space for a liquid hydrogen fuel tank which would be used for an experimental “scramjet” engine that would be mounted on the the ventral fin. The modified aircraft was also able to carry two external fuel tanks. It was hoped that additional propellant would allow the X-15A-2 to reach much higher speeds.

The first flight with the new configuration was an “envelope expansion” flight, intended to test the handling characteristics of the X-15A-2, and to jettison the tanks (which were empty on this flight) to evaluate the separation and trajectory as they fell away from the rocketplane in supersonic flight.

Boeing NB-52A Stratofortress 52-003, The High and Mighty One, with North American Aviation X-15A-2 56-6671 mounted to the pylon under its right wing. The external propellant tanks have been brightly painted to aid tracking after they are jettisoned. (U.S. Air Force)
Boeing NB-52A Stratofortress 52-003, The High and Mighty One, with North American Aviation X-15A-2 56-6671 mounted to the pylon under its right wing. The external propellant tanks have been brightly painted to aid tracking after they are jettisoned. (U.S. Air Force)

The X-15A-2 was dropped from the Boeing NB-52A Stratofortress 52-003, over Cuddeback Lake, 37 miles (60 kilometers) northeast of Edwards Air Force Base in the Mojave Desert of southern California. This was the only time during the 199-flight X-15 Program that this lake was used as a launch point.

The X-15 was released at 09:09:10.7 a.m., PST. Bob Rushworth ignited the Reaction Motors XLR99-RM-1 rocket engine and it ran for 84.1 seconds before its fuel supply was exhausted. This engine was rated at 57,000 pounds of thrust (253.549 kilonewtons).

The X-15 climbed to 70,600 feet (21,519 meters) and reached Mach 2.31 (1,514 miles per hour/2,437 kilometers per hour.)

The test flight went well. The external tanks jettisoned cleanly and fell away. The recovery parachute for the liquid oxygen tank did not deploy, however, and the tank was damaged beyond repair.

Rushworth and the X-15A-2 touched down on Rogers Dry Lake after a flight of 5 minutes, 1.6 seconds.

© 2016, Bryan R. Swopes

3 October 1967

Aviation, , , , , , , , , , , , , ,
Major William J. Knight, United States Air Force, with the North American Aviation X-15A-2, 56-6671. (U.S. Air Force)

3 October 1967: The 188th flight of the X-15 Program was the 53rd for the Number 2 aircraft, 56-6671. It had been extensively modified by North American Aviation to an X-15A-2 configuration following a landing accident which had occurred 9 November 1962. The fuselage was lengthened 28 inches (0.711 meters) to accommodate a liquid hydrogen fuel tank for a scramjet engine that would be added to the ventral fin, a new tank for additional hydrogen peroxide to generate steam for the rocket engine turbo pump, and external propellant tanks to allow the rocketplane to reach higher speeds and altitudes. The entire surface of the X-15 was covered with an ablative coating to protect the metal structure from the extreme heat it would encounter on this flight.

Minor issues delayed the takeoff but finally, after they were corrected, and with Pete Knight in the X-15’s cockpit, it was carried aloft under the right wing of Balls 8, a Boeing NB-52B Stratofortress, 52-008.

At 45,000 feet (13,716 meters) over Mud Lake, Nevada, the X-15 was droppeded at 14:31:50.9 local time. Knight fired the Reaction Motors XLR99-RM-1 rocket engine and began to climb and accelerate. After 60 seconds, the ammonia and liquid oxygen propellants in the external tanks was exhausted, so the the tanks were jettisoned to eliminate their weight and aerodynamic drag.

The X-15A-2 climbed to 102,100 feet (31,120 meters) and Pete Knight leveled off, still accelerating. After 140.7 seconds of engine burn, Knight shut the XLR99 down. He noticed that thrust seemed to decrease gradually and the X-15 continued to accelerate to 6,630 feet per second (2,021 meters per second), or Mach 6.72.

North American Aviation X-15A-2 56-6671 is carried to launch altitude under the right wing of the Boeing NB-52B Stratofortress 52-008. (U.S. Air Force)
North American Aviation X-15A-2 56-6671 is carried to launch altitude under the right wing of the Boeing NB-52B Stratofortress 52-008. The scramjet is attached to the ventral fin. (U.S. Air Force)
North American Aviation X-15A-2 56-6671 immediately after being released from the mothership, Boeing NB-52B Stratofortress 52-008, Balls 8, over Mud Lake, Nevada, 3 October 1967. The steam trail is hydrogen peroxide used to power the rocket engine turbopump. (U.S. Air Force)
North American Aviation X-15A-2 56-6671 immediately after being released from the mothership, Boeing NB-52B Stratofortress 52-008, Balls 8, over Mud Lake, Nevada, 3 October 1967. The steam trail is hydrogen peroxide used to power the rocket engine turbopump. (U.S. Air Force) 
The North American Aviation X-15A-2 56-6671 ignites the XLR99 engine after being released from the mothership, Balls 8, 3 October 1967. (U.S. Air Force)
The X-15A-2’s XLR99-RM-1 rocket engine ignites after release from the mothership, Balls 8, 3 October 1967. (U.S. Air Force) 

Shock waves from the dummy scramjet mounted on the ventral fin impinged on the fin’s leading edge and the lower fuselage, raising surface temperatures to 2,700 °F. (1,482 °C.) The Inconel X structure started to melt and burn through.

Pete Knight entered the high key over Rogers Dry Lake at 55,000 feet (16,764 meters) and Mach 2.2, higher and faster than normal. As he circled to line up for Runway One Eight, drag from the scramjet caused the X-15 to descend faster and this set him up for a perfect approach and landing. Because of heat damage, the scramjet broke loose and fell away from the X-15.

Knight touched down after an 8 minute, 17.0 second flight. His 4,520 mile per hour (7,274 kilometers per hour) maximum speed is a record that still stands.

Firefighters cool down the ventral fin of the North American Aviation X-15A-2 56-6671 after its last landing on Rogers Dry Lake, 3 October 1967.(U.S. Air Force)
Firefighters cool down the ventral fin of the North American Aviation X-15A-2 56-6671 after its final landing on Rogers Dry Lake, 3 October 1967.(U.S. Air Force)

The X-15A-2 suffered considerable damage from this hypersonic flight. It was returned to North American for repairs, but before they were completed, the X-15 Program came to an end. This was 56-6671’s last flight. It was sent to the National Museum of the United States Air Force where it is part of the permanent collection.

In a ceremony at the White House, President Lyndon B. Johnson presented the Harmon International Trophy to Major William J. Knight.

The Harmon International Trophy at the Smithsonian Institution National Air and Space Museum. (NASM)
The Harmon International Trophy at the Smithsonian Institution National Air and Space Museum. (NASM)

© 2016, Bryan R. Swopes