Tag Archives: Test Pilot

28 July 1935

Aviation, , , , , , , , , , , , , , , ,
Boeing Model 299, NX13372, photographed during its first flight, 28 July 1935. (The Boeing Company)
Boeing Model 299 X13372, photographed during its first flight, 28 July 1935. (The Boeing Company)
Boeing test pilot Les Tower. (Boeing)
Boeing’s Chief Test Pilot Leslie R. Tower.

28 July 1935, At Boeing Field, Seattle, Chief Test Pilot Leslie Ralph (“Les”) Tower and Louis Waite took off on the maiden flight of the Boeing Model 299, X13372,¹ a prototype four-engine long range heavy bomber. For approximately one-and-a-half hours, Tower flew back and forth between Tacoma and Fort Lewis. When he landed, he said, “It handles just like a little ship—a little bigger, of course.”

The Boeing Model 299 was a four-engine bomber operated by a crew of eight. It  was designed to meet a U.S. Army Air Corps proposal for a multi-engine bomber that could carry a 2,000 pound (907 kilogram) bomb load a distance of 2,000 miles (3,219 kilometers) at a speed greater than 200 miles per hour (322 kilometers per hour). Design of the prototype began in June 1934 and construction was started 16 August 1934. The Air Corps designated it B-299, and later, XB-17. It did not carry a military serial number, being marked with civil experimental registration X13372.

The Boeing Model 299 with Mount Rainier. (U.S. Air Force)
The Boeing Model 299 with Mount Rainier. (U.S. Air Force)

The Model 299 was 68 feet, 9 inches (20.955 meters) long with a wingspan of 103 feet, 9–3/8 inches (31.633 meters) and height of 14 feet, 11–5/16 inches (4.554 meters). Its empty weight was 21,657 pounds (9,823 kilograms). The maximum gross weight was 38,053 pounds (17,261 kilograms).

The prototype was powered by four air-cooled, supercharged, 1,690.537-cubic-inch-displacement (27.703 liter) Pratt & Whitney Hornet S1E-G nine-cylinder radial engines with a compression ratio of 6.5:1. The S1E-G was rated at 750 horsepower at 2,250 r.p.m., and 875 horsepower at 2,300 r.p.m. for takeoff, using 87-octane gasoline. They turned 11 foot, 6 inch (3.505 meters) diameter, three-bladed, Hamilton Standard Hydromatic constant-speed propellers through a 3:2 gear reduction. The S1E-G was 4 feet, 1.38 inches (1.254 meters) long, 4 feet, 6.44 inches (1.383 meters) in diameter and weighed 1,064 pounds (483 kilograms)

Boeing Model 299. (U.S.  Air Force)

In flight testing, the Model 299 had a cruise speed of 204 miles per hour (328 kilometers per hour) and a maximum speed of 236 miles per hour (380 kilometers per hour) at 10,000 feet (3,048 meters). The service ceiling was 24,620 feet (7,504.2 meters). Its maximum range was 3,101 miles (4,991 kilometers). Carrying a 2,573 pounds (1,167 kilograms) load of bombs, the range was 2,040 miles (3,283 kilometers).

Boeing 299 NX13372, all engines running.
Boeing 299 X13372, all engines running.

The XB-17 could carry eight 500 pound (226.8 kilogram) bombs in an internal bomb bay. Defensive armament consisted of five air-cooled Browning .30-caliber machine guns.

Nose turret of the Boeing Model 299, photographed 24 July 1935. (U.S. Air Force)
Nose turret of the Boeing Model 299, photographed 24 July 1935. (The Boeing Company)

X13372 was destroyed when it crashed on takeoff at Wright Field, Dayton, Ohio, 30 October 1935. An Army Air Corps pilot making his first familiarization flight neglected to remove the control locks. This incident led directly to the creation of the ”check list” which is used by all aircraft crew members.

Waist gun position of the Boeing 299. (U.S. Air force)
Waist gun position of the Boeing 299. (The Boeing Company)

Designated XB-17 by the Army Air Corps, this airplane and the YB-17 pre-production models that followed would undergo several years of testing and improvement before entering production as the B-17 Flying Fortress, a legendary airplane of World War II. By the end of the war 12,731 B-17s had been built by Boeing, Douglas and Lockheed Vega.

Boeing Model 299 NX13372, designated XB-17, at Wright Field, Ohio, 1935. (U.S. Air Force)
Boeing Model 299 X13372, designated XB-17, at Wright Field, Ohio, 1935. (U.S. Air Force)

Leslie Ralph Tower was born at Sisseton, South Dakota, 21 January 1903. He was the first of three children of Ralph R. Tower, a farmer who would later serve as a state senator for Montana, and Mayme Amanda Johnson Tower, a Swedish immigrant.

Les Tower attended high school at Polson, Montana, graduating in 1922. He then attended the University of Washington, where he studied engineering. He was a member of the Radio Club.

Tower enlisted in the United States Army as an aviation cadet, training at Brooks and Kelly airfields in Texas. He then served with the 2nd Bombardment Squadron at Langley Field, Virginia.

In 1925 Tower started working for Boeing as a draftsman, but soon began test flying new airplanes, which included the B-9 bomber and the Model 247 commercial airliner. He also demonstrated and delivered Boeing airplanes around the world.

On 20 August 1935, Tower and Louis Wait flew the Model 299 from Seattle to Dayton, approximately 2,100 miles, in 9 hours, 3 minutes, averaging 233 miles per hour (375 kilometers per hour).

Les Tower was aboard the XB-17 as an observer during the 30 October flight. He saw that the control locks had not been released and tried to reach them, but was unable. In the fire that followed the crash, Tower suffered severe burns to his face, right arm and both legs.

Leslie Ralph Tower died of his injuries 19 November 1935 at Miami Valley Hospital in Dayton. His remains were transported by train, escorted by Army airplanes, and were buried at Lakeview Cemetery, Polson, Montana.

¹ At that time, experimental and restricted category aircraft were prohibited from displaying the letter “N” at the beginning of their registration mark.

© 2020, Bryan R. Swopes

27 July 1972

Aviation, , , , , , , , ,
Irving L. Burrows prepares for teh first flight of the pre-production YF-15A-1-MC Eagle air superiority fighter at Edwards Air Force Base, California.
Irving L. Burrows prepares for the first flight of the pre-production YF-15A-1-MC Eagle air superiority fighter at Edwards Air Force Base, California. (U.S. Air Force)

27 July 1972: McDonnell Douglas Chief Experimental Test Pilot Irving L. Burrows made the first flight of the prototype YF-15A-1-MC Eagle, 71-0280, at Edwards Air Force Base, California.

Irving L. Burrows
Irving L. Burrows

The F-15A Eagle is a single-seat, twin-engine air superiority fighter, built by the McDonnell Douglas Corporation at St. Louis, Missouri. The fighter has outstanding acceleration and maneuverability. It is 63 feet, 9 inches (19.431 meters) long, with a wingspan of 42 feet, 9.75 inches (13.049 meters) and overall height of 18 feet, 7.5 inches (5.677 meters).

The first pre-production prototype McDonnell Douglas F-15 Eagle, YF-15A-1-MC 72-0280, on its first flight near Edwards Air Force Base, California, 27 July 1972. (U.S. Air Force)

The wings’ leading edges are swept to 45°. The angle of incidence is 0°. The wings have 1° anhedral. The total wing area is 608 square feet (56.5 square meters).

The F-15A has an empty weight of 25,780 pounds (11,694 kilograms), and maximum takeoff weight of 44,497 pounds (20,184 kilograms).

McDonnell Douglas YF-15A-1-MC Eagle 71-0280, with a McDonnell Douglas RF-4C Phantom II chase plane, in flight near Edwards AFB. (U.S. Air Force)

The fighter was powered by two Pratt & Whitney JTF22A-25A (F100-PW-100) turbofan engines. The F100 is a two-spool, axial-flow afterburning turbine engine with a 3-stage fan section; 10-stage compressor; single chamber combustion section; and 4-stage turbine (2 low- and 2 high-pressure stages). The F100-PW-100 has a maximum continuous power rating of 12,410 pounds of thrust (55.20 kilonewtons) and intermediate rating of 14,690 pounds (65.34 kilonewtons), (30 minute limit). Its maximum power rating is 23,840 pounds (106.05 kilonewtons) with afterburner (5 minute limit). The F100-PW-100 is  16 feet, 4.3 inches (4.986 meters) long, 3 feet, 10.5 inches (1.181 meters) in diameter, and weighs 3,179 pounds (1,442 kilograms).

An early production McDonnell Douglas F-15A-8-MC Eagle, 73-0090, at Luke Air Force Base, Arizona. The fighter is painted “air superiority blue.” (U.S. Air Force)

The Eagle is a Mach 2.5+ fighter. The cruise speed of the F-15A Eagle is 502 knots (578 miles per hour/930 kilometers per hour). It has a maximum speed of 1,434 knots (1,650 miles per hour/2,656 kilometers per hour) at 45,000 feet (13,716 meters)—Mach 2.503. The service ceiling is 63,050 feet (19,218 meters). It can climb 67,250 feet per minute (342 meters per second), and with a thrust-to-weight ratio of 1.15:1, the fighter could climb straight up.

The The F-15A’s combat radius is 638 nautical miles (734 statute miles/1,182 kilometers). Its maximum ferry range is 2,362 nautical miles (2,718 statute miles/4,374 kilometers).

A McDonnell Douglas F-15 Eagle over the White Sands Missile Range banks away from the camera to display its air-to-air missile armament, 1 May 1980.. (Technical Sergeant Frank Garzelnick, U.S. Air Force)

The F-15A is armed with one General Electric M61A1 Vulcan 20mm rotary cannon with 938 rounds of ammunition, four AIM-7F Sparrow radar-guided missiles and four AIM-9E/L Sidewinder infrared-homing missiles. The fighter could also carry a variety of bombs.

There were 12 pre-production F-15 aircraft, serial numbers 71-0280–71-0291. 384 F-15A fighters were built from 1972 to 1979, before production switched to the improved F-15C. The last F-15A Eagle in U.S. Air Force service, F-15A-19-MC 77-0098, was retired from the Oregon Air National Guard, 16 September 2009.

The last McDonnell Douglas F-15A Eagle in U.S. Air Force service. F-15A-19-MC 77-0098, prepares for its final flight from Portland, Oregon, to Davis-Monthan AFB, 16 September 2009. The pilot was LCOL Steve Beauchamp, 123rd Fighter Squadron, 142nd Fighter Wing, Oregon Air National Guard. (U.S. Air Force) 09016-F-8260H-184

The first YF-15A, 71-0280, is on display at Lackland Air Force Base, Texas.

© 2018, Bryan R. Swopes

26 July 1958

Aviation, , , , , , , , , , , ,
Captain Iven C. Kincheloe, Jr., U.S. Air Force, in the cockpit of a Lockheed F-104 Starfighter. (U.S. Air Force)

26 July 1958: United States Air Force test pilot Captain Iven Carl Kincheloe, Jr., took off from Edwards Air Force Base in Lockheed F-104A-15-LO Starfighter 56-0772, acting as a chase plane for another F-104A which was flown by a Lockheed test pilot, Louis W. Schalk, Jr.

As the two supersonic interceptors began their climb out from the runway, a small control cable deep inside Kincheloe’s fighter failed, allowing the inlet guide vane of the F-104’s General Electric J79-GE-3 turbojet engine to close. With the suddenly decreased airflow the engine lost power and the airplane started to descend rapidly.

Captain Kincheloe radioed, “Edwards, Mayday, Seven-Seventy-Two, bailing out.”

Lockheed F-104A-15-LO Starfighter, 56-0772. (U.S. Air Force)
Lockheed F-104A-15-LO Starfighter 56-0772. (U.S. Air Force)

The early F-104 Starfighters had a Stanley Aviation Corporation Type B ejection seat that was catapulted or dropped by gravity from the bottom of the cockpit. 56-0772 was equipped with an improved Stanley Type C ejection seat. With the Starfighter well below 2,000 feet (610 meters), Kincheloe apparently thought that he needed to roll the airplane inverted before ejecting. This was actually not necessary and delayed his escape.

The XF-104 had a downward-firing ejection seat, intended to avoid the airplane's tall vertical tail. Production aircraft used an upward-firing seat. (Lockheed)
The early F-104s had a downward-firing Stanley B ejection seat, intended to avoid the airplane’s tall vertical tail. Later production aircraft used an upward-firing seat. (Lockheed Martin)

By the time he had separated from the seat and could open his parachute, he was below 500 feet (152 meters). The parachute did open, but too late. Iven Kincheloe was killed on impact. His airplane crashed into the desert floor just over 9 miles (14.5 kilometers) from the west end of Runway 22 and was totally destroyed. Today, a large crater scattered with fragments of Kincheloe’s F-104 is still clearly visible.

Iven Kincheloe was just 30 years old.

Lockheed F-104A-15-LO Starfighter 56-0772 is the interceptor closest to the camera in this photograph. (U.S. Air Force)
Lockheed F-104A-15-LO Starfighter 56-0772 is the interceptor closest to the camera in this photograph. (U.S. Air Force)

Iven Carl Kincheloe, Jr., was a legendary test pilot. He was born 2 July 1928 in Wayne County, Michigan, the son of Iven Carl Kincheloe, a farmer, and Francis Emma Wilde. He started flying lessons when he was 14 years old, and by the time he was legally allowed to solo—on his 16th birthday—he had already accumulated over 200 flight hours. He entered the Air Force Reserve Officer Training Program (ROTC) at Purdue University, West Lafayette, Indiana, where he was an engineering student. While there, he met Air Force test pilot Chuck Yeager and decided that test flying was the career area that he wanted to pursue.

Iven Carl Kincheloe, Jr., Purdue Class of 1949. (1949 Debris)

At Purdue, Kincheloe was a member of the Sigma Phi Epsilon (ΣΦΕ) fraternity, played football and managed the track team. He was a member of a military honor society, the Scabbard and Blade, and the Gimlet Club, a booster organization supporting varsity sports at the university. Iven Kincheloe graduated in 1949 with a Bachelor of Science degree in Aeronautical Engineering. He was commissioned as a second lieutenant, United States Air Force Reserve, 17 June 1949.

On graduation, Kincheloe was sent to Arizona to begin his Air Force pilot training. After graduating, Second Lieutenant Kincheloe was sent to Edwards Air Force Base in southern California to work on the new North American Aviation F-86E Sabre.

Lieutenant Kincheloe deployed to Korea as a fighter pilot with the 4th Fighter Interceptor Wing in August 1951, flying the F-86E Sabre as an escort for bomber formations. He was transferred to the 25th Fighter Interceptor Squadron, 51st Fighter Interceptor Group, and immediately began to shoot down enemy Mikoyan-Gurevich MiG-15 fighters. He was soon an “ace” with five confirmed kills.

Lieutenant Iven C. Kincheloe, Jr., in the cockpit of his North American Aviation F-86F-10-NA Sabre, 51-2731, named Ivan. (U.S. Air Force)
Lieutenant Iven C. Kincheloe, Jr., in the cockpit of his North American Aviation F-86E-10-NA Sabre, 51-2731, named “Ivan,” Korea, circa 1951. (U.S. Air Force)

After his combat tour (131 missions) in Korea, Iven Kincheloe was assigned as an exchange student to the Empire Test Pilots’ School at RAE Farnborough, England. After completing the ten-month British training program in 1955, Kincheloe was sent back to Edwards Air Force Base.

One of the most skilled test pilots at Edwards, Iven Kincheloe flew every type of fighter, as well as the Bell X-2 rocketplane, which he flew to 126,200 feet (38,465 meters), 7 September 1956. He was the first pilot to climb higher than 100,000 feet (30,480 meters) and was considered to be “the first man in space.” For this flight, Kincheloe was awarded the Mackay Trophy, “For outstanding contributions to the science of aviation by flying the Bell X-2 to an altitude considerably higher than had ever been reached before by a piloted aircraft.”

Kincheloe was scheduled to become the primary Air Force pilot on the upcoming North American Aviation X-15 Program. That would have been followed by the Man In Space Soonest project, which would have launched Kincheloe into orbit with an X-15B second stage launched by an Atlas intercontinental ballistic missile.

Captain Iven C. Kincheloe, Jr., with his son, Iven III, and Dorothy W. Heining Kincheloe. Captain Kincheloe is wearing a David Clark Co. MC-3 capstan-type partial-pressure suit and MA-3 helmet. The airplane is a Lockheed F-104A Startfighter. (Photograph courtesy of Neil Corbett, Test & Research Pilots, Flight Test Engineers)

Captain Kincheloe married Miss Dorothy W. Heining at Monterey, California, 20 August 1955. They had two children, Iven Carl Kincheloe III and Jeanine Kincheloe, who was born several months after her father’s death.

Captain Iven Carl Kincheloe, Jr., was awarded the Silver Star, the Legion of Merit (posthumous), the Distinguished Flying Cross with two oak leaf clusters (three awards), and the Air Medal with three oak leaf clusters (four awards), Presidential Unit Citation with oak leaf cluster (two awards), National Defense Service Medal, Korean Service Medal with three service stars, Air Force Longevity Service Award, the Republic of Korea Presidential Unit Citation, United Nations Korean Service Medal, and the Republic of Korea Korean War Service Medal. In 1959, Kincheloe Air Force Base, Michigan, was named in his honor.

Captain Kincheloe is buried at the Arlington National Cemetery.

Captain Iven Carl Kincheloe, Jr., United states Air Force. LIFE Magazine via Jet Pilot Overseas)
Captain Iven Carl Kincheloe, Jr., United States Air Force. (LIFE Magazine via Jet Pilot Overseas)

© 2018, Bryan R. Swopes

23 July 1999, 16:31:00 UTC, T minus Zero

Space Flight, , , , , , , , , , ,
Colonel Eileen Marie Collins, U.S. Air Force, wearing ACES suit. (Annie Leibovitz)
Colonel Eileen Marie Collins, U.S. Air Force, wearing ACES suit. (Annie Leibovitz/NASA Art Program)

23 July 1999: at 12:31 a.m. Eastern Daylight Time (16:31:00 UTC), the Space Shuttle Columbia (OV-102) lifted off on its 26th mission, STS-93, to place the Chandra X-ray Observatory in orbit. The total mission duration was 4 days, 22 hours, 49 minutes, 37 seconds.

In command was Colonel Eileen Marie Collins, United States Air Force, on her third shuttle flight. This was the first time that a space shuttle mission had been commanded by a woman.

Colonel Collins had previously served as pilot aboard Discovery STS-63 and Atlantis STS-84. She would later command Discovery (STS-114), the “Return To Flight” mission following the loss of Columbia. She logged 38 days, 10 hours of space flight. Eileen Collins retired in 2006.

Space Shuttle Columbia (STS-93) launch from Launch Complex 39B, Kennedy Space Center, 16:31:00 UTC, 23 July 1999. (NASA)

© 2017, Bryan R. Swopes

23 July 1956

Aviation, , , , , , , , , , , , ,
Bell X-2 46-674 airdropped from Boeing EB-50D Superfortress 48-096 near Edwards Air Force Base, California. (U.S. Air Force)
Brigadier General Frank Kendall Everest, United States Air Force
Brigadier General Frank Kendall Everest, United States Air Force

23 July 1956: Lieutenant Colonel Frank Kendall “Pete” Everest, United States Air Force, became “The Fastest Man Alive” when he flew the USAF/NACA/Bell X-2 rocket plane, serial number 46-674, to Mach 2.87 (1,957 miles per hour, 3,150 kilometers per hour) at 87,808 feet (26,764 meters). The X-2 was air-dropped from Boeing EB-50D Superfortress 48-096, near Edwards Air Force Base, California.

The X-2 was a joint project of the U.S. Air Force and NACA (the National Advisory Committee for Aeronautics, the predecessor of NASA). The rocketplane was designed and built by Bell Aircraft Corporation of Buffalo, New York, to explore supersonic flight at speeds beyond the capabilities of the earlier Bell X-1 and Douglas D-558-2 Skyrocket. In addition to the aerodynamic effects of speeds in the Mach 2.0–Mach 3.0 range, engineers knew that the high temperatures created by aerodynamic friction would be a problem, so the aircraft was built from Stainless Steel and K-Monel, a copper-nickel alloy.

The Bell Aircraft Corporation X-2 was 37 feet, 10 inches (11.532 meters) long with a wingspan of 32 feet, 3 inches (9.830 meters) and height of 11 feet, 10 inches (3.607 meters). Its empty weight was 12,375 pounds (5,613 kilograms) and loaded weight was 24,910 pounds (11,299 kilograms).

The X-2 was powered by a throttleable Curtiss-Wright XLR25-CW-1 rocket engine that produced 2,500–15,000 pounds of thrust (11.12–66.72 kilonewtons) burning alcohol and liquid oxygen. The engine used two rocket chambers and had pneumatic, electrical and mechanical controls. The smaller chamber could produce a maximum 5,000 pounds of thrust, and the larger, 10,000 pounds (22.24 and 44.48 likonewtons, respectively). Professor Robert H. Goddard, “The Father of Modern Rocketry,” authorized Curtiss-Wright to use his patents, and his rocketry team went to work for the Curtiss-Wright Rocket Department. Royalties for use of the patents were paid to the Guggenheim Foundation and Clark university. Professor Goddard died before he could also make the move

Rather than use its limited fuel capacity to take off and climb to altitude, the X-2 was dropped from a modified heavy bomber as had been the earlier rocketplanes. The launch altitude was 30,000 feet (9,144 meters). After the fuel was exhausted, the X-2 glided to a touchdown on Rogers Dry Lake at Edwards Air Force Base.

A four-engine Boeing B-50A Superfortress bomber, serial number 46-011, was modified as the ”mothership.” A second Superfortress, B-50D-95-BO 48-096, was also modified to carry the X-2, and was redesignated EB-50D. During the flight test program, the X-2 reached a maximum speed of Mach 3.196 (2,094 miles per hour, 3,370 kilometers per hour) and a maximum altitude of 126,200 feet (38,466 meters).

Frank Kendall Everest was a fighter pilot and flight instructor during World War II. He flew combat missions in both the Mediterranean and China-Burma-India Theaters of Operation. In May 1945 he was shot down. Everest was captured by the Japanese, held as a prisoner and tortured until the end of the war. After the war, Everest flew as a test pilot at Wright-Patterson Air Force Base, Ohio, and then at Edwards Air Force Base. On 23 July 1956, he was The Fastest Man Alive. Pete Everest retired as a brigadier general in 1970, and died in 2004.

Lieutenant Colonel Frank Kendall Everest, U.S. Air Force, wearing a David Clark Co. T-1 capstan-type partial-pressure suit for protection at high altitude, with a Bell X-2 rocketplane at Edwards AFB, circa 1956. (U.S. Air Force)

© 2017, Bryan R. Swopes