Tag Archives: World Record for Time to Climb to a Height of 3000 Meters

30 December 1968

Chief Warrant Officer James P. Ervin, United States Army (FAI)
Chief Warrant Officer 4 James P. Ervin, United States Army (FAI)
CW4 William T. Lamb

30 December 1968: At the Sikorsky Aircraft Corporation plant at Stratford, Connecticut, Chief Warrant Officer 4 James Paul Ervin, Jr., United States Army, set two Fédération Aéronautique Internationale (FAI) World Records for Time to Altitude while flying a Sikorsky CH-54A Tarhe. The helicopter’s co-pilot for this flight was CW4 William T. Lamb. The “Sky Crane” reached 3,000 meters (9,842.52 feet) in 1 minute, 38.2 seconds, and 9,000 meters (29,527.56 feet) in 7 minutes, 54 seconds.¹ (It climbed through 6,000 meters (19,686 feet) in 2 minutes, 58.9 seconds.²)

Several attempts to break the existing time to altitude records had been made on 29 and 30 December. Erwin decided to deviate from Sikorsky’s recommended climb profile and, instead, climbed vertically until reaching 20,000 feet, and then returned to Sikorsky’s profile.

On the same date, CW4 Lamb, with Erwin as co-pilot, established a World Record for Altitude in Horizontal Flight, of 9,596 meters (31,483 feet).³

According to an article in U.S. Army Aviation Digest, during the record attempt flights, the regional air traffic control center called a commercial airliner which was cruising at 17,000 feet,

“. . . be advised there’s a helicopter at your 9 o’clock position descending out of 27,000 feet at a rate of 4,000 feet per minute.”

The airliner replied, “Good lord, you mean they’re up here now?”

Another pilot on the frequency asked, “What kind of helicopter is that?”

Mr. Ervin was awarded the Distinguished Flying Cross for his achievement.

A third U.S. Army aviator involved in the record attempts was Major James H. Goodloe, as was a Sikorsky test pilot, John J. Dixon.

FAI record-setting Sikorsky CH-54A Tarhe (FAI)
FAI record-setting Sikorsky CH-54A Tarhe (FAI)

The Sikorsky CH-54A Tarhe is a large single-main-rotor/tail rotor helicopter, specifically designed to carry large external loads. In U.S. Army service, it had a crew of five: pilot, co-pilot, third pilot and two mechanics. The third pilot was in a rear-facing cockpit position and flew the helicopter while it was hovering to pick up or position an external load.

The CH-54A is 88 feet, 5.9 inches (26.972 meters) long and 25 feet, 4.7 inches (7.739 meters) high. The main rotor has six blades and turns counter-clockwise, seen from above. (The advancing blade is on the helicopter’s right side.) The main rotor has a diameter of 72 feet (21.946 meters). The main rotor blades have a chord of 1.97 feet (0.601 meters) and incorporate a twist of -13°. The tail rotor has four blades and is placed on the left side of a vertical pylon in a pusher configuration. The tail rotor turns clockwise, as seen from the helicopter’s left side. (The advancing blade is below the axis of rotation.) The diameter of the tail rotor is 16 feet (4.877 meters). The chord of the tail rotor blade is 1.28 feet (0.390 meters).

The helicopter has an empty weight of 19,120 pounds (8,673 kilograms) a design gross weight of 38,000 pounds (17,237 kilograms) and overload gross weight of 42,000 pounds (19,051 kilograms).

Sikorsky CH-54A Tarhe 68-18448, Nevada National Guard, 16 November 1989. (Mike Freer/Wikipedia)

The CH-54A is powered by two Pratt & Whitney JFTD12A-4A (T73-P-1) turboshaft engines, each rated at 4,000 shaft horsepower at 9,000 r.p.m. (N2) maximum continuous power at Sea Level, and 4,500 shaft horsepower at 9,500 r.p.m. (N2) for takeoff, 5-minute limit, or 30 minutes, with one engine inoperative (OEI). The maximum gas generator speed (N1) is 16,700 r.p.m. The T73-P-1 is an axial-flow free-turbine turboshaft engine with a 9-stage compressor section, 8 combustion chambers and a 4-stage turbine section (2-stage gas generator and 2-stage free turbine). It is 107.0 inches (2.718 meters) long, 30.0 inches (0.762 meters) in diameter, and weighs 966 pounds (438 kilograms). The helicopter’s main transmission is limited to a maximum 6,600 horsepower.

It has a useful load of 22,880 pounds (10,342 kilograms) and can carry a payload of 20,000 pounds (9,072 kilograms) from a single point cargo hoist.

The CH-54A has a maximum cruise speed of 115 knots (132 miles per hour, 213 kilometers per hour). It’s range is 217 nautical miles (250 miles,  402 kilometers). The CH-54A has a hover ceiling in ground effect (HIGE) of 10,600 feet (3,231 meters) and its service ceiling is 13,000 feet (3,962 meters).

The U.S. Army ordered 54 CH-54A and 35 CH-54B Tarhes. Sikorsky produced another 12 civil-certified S-64E and S-64F Skycranes. Army CH-54s were retired from service in 1995. Sikorsky sold the type certificate to Erickson Air-Crane, Inc., Medford, Oregon. Erickson operates a fleet of Skycranes for heavy lift, logging and fire fighting, and also produces parts and new helicopters for worldwide customers.

The United States Army has a tradition of using Native American names for its aircraft. Tarhe (pronounced tar-HAY) was a famous chief, or sachem, of the Wyandot People of North America, who lived from 1742–1818. He was very tall and the French settlers called him “The Crane.”

James Paul Ervin, Jr., was born 2 October 1931, in Arkansas. He was the second child of James Paul Erwin and Ruth Booker Ervin. He joined the United States Army in 1948. In 1955, he married his wife, Theresa M. (“Terry”) Ervin. They resided in Columbus, Georgia.

CW4 Ervin was considered a pioneer of Army Aviation. He was one of the first pilots to experiment with armed helicopters, and he served with the first transportation company to be equipped with the Sikorsky CH-34 Choctaw and CH-37 Mohave helicopters. During the Vietnam War, he was assigned to the 478th Aviation Company (Heavy Helicopter). Mr. Ervin retired from the United States Army in July 1969 after 21 years of service.

At 1735, 2 September 1969, as a civilian pilot working for ERA Helicopters in Alaska, Ervin was flying a Sikorsky S-64E Skycrane, N6964E, on the North Slope near Prudhoe Bay, when the helicopter broke up in flight and crashed near a drilling site, Southeast Eileen. Chief Erwin and two others aboard, Byron Davis and Allen Bryan, were killed.

The National Transportation Safety Board determined that a tail rotor pitch control link failed due to a fatigue fracture. The NTSB accident report also cited improper factory installation as a factor.

At the time of the accident, Erwin had a total of 4,787 flight hours with 830 hours in type. He was 37 years old. James Paul Erwin, Jr., is buried at the Marietta National Cemetery, Marietta, Georgia.

An Erickson Air-Crane, Inc. Sikorsky S-64 Skycrane drops water on a forest fire. (Sikorsky Archives)
An Erickson Air-Crane, Inc., Sikorsky S-64 Skycrane drops water on a forest fire. (Igor I. Sikorsky Historical Archives)

¹ FAI Record File Numbers 9944 and 9961.

² Many sources state that CW4 Erwin set a record for Time to 6,000 meters, and some give the elapsed time as 3 minutes, 31.5 seconds. The FAI Records Database does not list this record.

³ FAI Record File Number 9919.

© 2017 Bryan. R. Swopes

18–24 October 1961

Lieutenant Colonel Francis M. Carney, USAF. (FAI 13135-1.jpg)

18–24 October 1961: Lieutenant Colonel Francis Melvin (“Blackie”) Carney, United States Air Force, flying a Kaman HH-43B Huskie, 60-0263, set a series of four Fédération Aéronautique Internationale (FAI) world flight records at Bloomfield, Connecticut.

On 18 October 1961, Lieutenant Colonel Carney set an FAI World Record for Altitude Without Payload when he flew 60-0263 to 10,010 meters (32,841 feet).¹ The following week, on 24 October 1961, Colonel Carney set three more world records, flying the HH-43B to 3,000 meters (9,853 feet) in 2 minutes, 41.5 seconds;² 6,000 meters (19,685 feet) in 6 minutes 49.3 seconds;³ and to 9,000 meters (29,528 feet) in 14 minutes, 31 seconds.⁴

Kaman HH-53B Huskie 60-0263. *Fédération Aéronautique Internationale 13135-2)

This same helicopter, flown by Captain Walter G. McMeen, set an FAI World Record for Altitude with a 1000 kilogram Payload to an altitude of 8,037 meters (26,368 feet) over the Kaman plant at Bloomfield, Connecticut, 25 May 1961.⁵ The following summer, Captain Richard H. Coan set an FAI World Record for Distance Over a Closed Circuit Without Landing of 1,055.16 kilometers (655.65 miles) at Mono Lake, California;⁶ Captain Chester R. Radcliffe, Jr., set an FAI World Record for Distance Without Landing when he flew it from Hill Air Force Base, Utah, to Springfield, Minnesota, a distance of 1,429.80 kilometers (888.44 miles), 5 July 1962.⁷

Kaman HH-43B Huskie 60-263. (FAI)

In 1962, Lieutenant Colonel Carney, then commanding the 3638th Flying Training Squadron (Helicopter), U.S. Air Force, was awarded the American Helicopter Society (now, the Vertical Flight Society) Frederick L. Feinberg Award “For the establishment of four new world records for helicopters on 18 and 24 October, 1961. The records established were the maximum altitude for a Class EID helicopter and three time-to-climb records for all types of helicopters.”

Francis Melvin Carney was born at Roxborough, Pennsylvania, 14 November 1921. He was the son of Francis Jerome Carney, an electrician, and Maggie May Ferguson Carney. His father died in 1929.
Carney registered for Selective Service (conscription), 16 February 1942. He was described as having a light complexion with brown hair and blue eyes. He was 6 feet (1.83 meters) tall and weighed 165 pounds (73 kilograms). Three days earlier, 13 February 1942, he had enlisted in the Army of the United States (AUS) at the U.S. Customs House, Philadelphia, Pennsylvania.
On 12 March 1942, Carney was assigned as an Aviation Cadet, Air Corps, and began flight training. On completion of training, he was commissioned as a second lieutenant, Air Reserve, 22 April 1943.
Lieutenant Carney married Miss Eleanor May Childs, circa 1944. They would have four children, Eric Lance Carney, Ronald Jerome Carney, Randall Wayne Carney, and Robin Carney.
Lieutenant Carney received a permanent commission as a first lieutenant, Air Corps, United States Army, 10 October 1947, with date of rank retroactive to 22 April 1946. When the United States Air Force was established as a separate military service, 1st Lieutenant Carney was transferred from the U.S. Army to the U.S. Air Force.
In 1952 Captain Carney transitioned to helicopters.
With insufficient fuel to return to Shaw Air Force Base, the two H-19s were refueled at the scene. (U.S. Air Force/The State, 28 March 1955, Page 8-A, Columns 1–3)
On 27 March 1955, Major Carney flew one of two Sikorsky H-19 Chickasaw helicopters of the 363rd Tactical Reconnaissance Wing, Shaw Air Force Base, Sumter, South Carolina, in the nighttime rescue of 93 men, women, and children from several tiny islands in Lake Marion, near Eutawville, South Carolina. A sudden increase in wind raised 4 foot waves on the lake, endangering them. One of the islands was too small to land, so Carney’s co-pilot, Captain Robert L. Hess (also reported as Warren C. Hess), climbed down to help lift victims aboard. Major Carney, Captain Hess, 1st Lieutenant Ronald L. Ingraham, pilot of the second H-19, and several others received the Air Force Commendation Medal, presented 29 March by Major General Edward Julius Timberlake, Jr., commanding Ninth Air Force.
Major Carney climbs down from the cockpit of his Sikorsky H-19, while Captain Robert L. Hess stands at right. (Crowson/ The Sumpter Daily Item, 28 March 1955, Page 6, Columns 7 and 8)
In 1955 Major Carney was assigned as commanding officer, 24th Helicopter Squadron at Sewart Air Force Base, Smyrna, Tennessee, flying the Piasecki H-21B Work Horse, providing troop carrier support to US Army; flew to CA 10 October 1956 deployed to Tachikawa Air Base, Japan, aboard the Casablanca-class utility aircraft carrier USS Corregidor (CVU-58).
Lieutenant Colonel Carney commanded the 3638th Flying Training Squadron (Helicopter), 3635th Combat Crew Training Wing (Advanced) at Stead AFB, Reno, Nevada, 1959–1964. Initially, pilots were trained in the H-19B and H-21B helicopters. In 1964, Carney deployed to Vietnam.
Lieutenant Colonel Carney retired from the U.S. Air Force, 20 September 1965. During his 23 years of military service, he had flown as a fighter pilot in World War II and the Korean War, and a helicopter pilot during the Vietnam War. He had been awarded the Distinguished Flying Cross.
Following his retirement for the Air Force, Carney served as Chief Pilot, Carson Helicopters, Inc., Perkasie, Pennsylvania, then in 1984, he opened a helicopter flight school at Quakertown Airport (UKT), Pennsylvania, using two Hiller UH-12C three-place helicopters.
“Blackie” Carney with a Hiller UH-12C at Quakertown Airport, 1984. (Don Boorse/News Herald, 22 February 1984) columns –6
28 June 1994, Carney was flying his green and white 1947 Piper PA-12 Supercruiser, N3807M (s/n 12-2729). While on approach to the Flying M Aerodrome (P91), Heidelberg Township, Germansville, Pennsylvania, he was caught in a downdraft. His airplane flipped over on landing. Carney suffered one fractured vertebrae in his neck and two in his lower back lower back. He was transported by ambulance and admitted to the Lehigh Valley Hospital, Lehigh Township, Pennsylvania, where he remained in stable condition.
Blackie Carnet’s green and white Piper PA-12 Supercruiser, N3807M, upside down at the Flying M Aerodrome (P91), Heidelberg Township, Pennsylvania, 28 June 1994. (Don Fisher/The Morning Call, 29 June 1994, Page 12, Columns 5–7)
Lieutenant Colonel Carney died at Bedminster, Pennsylvania, 30 July 1996. His remains were interred at White Marsh Memorial Park, Prospectville, Pennsylvania.
The record-setting Kaman HH-43B-KA Huskie, 60-0263, at the National Museum of the United States Air Force. (U.S. Air Force)

The Kaman Aircraft Corporation Huskie was used by the U.S. Air Force, U.S. Navy and Marine Corps, primarily for short range rescue operations. It was operated by two pilots and two rescue crewmen.

A turboshaft engine drove a unique system of counter-rotating and intermeshing rotors to provide lift, thrust and directional control. The counter-rotation cancelled the torque effect so no anti-torque, or tail, rotor was necessary. This allowed all of the engine’s power to drive the main rotor system.

The fuselage of the H-43B was 25 feet, 2 inches (7.671 meters) long. Each rotor had a diameter of 47 feet, 0 inches (14.326 meters). It’s height was 15 feet, 6½ inches (4.737 meters). The helicopter’s empty weight was 4,470 pounds (2,028 kilograms) and its maximum gross weight was 8,800 pounds (3,992 kilograms).⁸

The H-43B was powered by one Lycoming T53-L-1B turboshaft engine, rated at 860 shaft horsepower at 21,510 r.p.m. The engine uses a 5-stage axial-flow, 1 stage centrifugal-flow, compressor with a single stage gas producer turbine and single-stage power turbine. A reverse-flow combustion section allows significant reduction in the the engine’s total length. The power turbine drives the output shaft through a 3.22:1 gear reduction. The T53-L-1 is 3 feet, 11.8 inches (1.214 meters) long and 1 foot, 11.0 inches (0.584 meters) in diameter. It weighs 460 pounds (209 kilograms).

The Huskie’s economical cruise speed was 98 miles per hour (158 kilometers per hour), and the maximum speed was 120 miles per hour (193 kilometers per hour). Its hover ceiling out of ground effect (HOGE) was 18,000 feet (5,486 meters), and in ground effect (HIGE) was 20,000 feet (6,096 meters) and it had a range of 235 miles (378 kilometers).

With the call sign Pedro, the HH-43 was a rescue helicopter that served in combat during the Vietnam War.

The record-setting Kaman HH-43B Huskie 60-0263 was last assigned to Detachment 3, 42nd Aerospace Rescue and Recovery Squadron, Kirtland Air Force Base, New Mexico. It is in the collection of the National Museum of the United States Air Force, Wright-Patterson Air Force Base, Ohio.

¹ FAI Record File Number 1870

² FAI Record File Number 13135

³ FAI Record File Number 13056

⁴ FAI Record File Number 13137

⁵ FAI Record File Number 1258

⁶ FAI Record File Number 13154

⁷ FAI Record File Number 13208

⁸ Maximum overload gross weight is 9,150 pounds (4,150 kilograms) at a load factor of 2.0

© 2020, Bryan R. Swopes

13 June 1962

Captain Richard H. Coan, USAF, at Mono Lake, California, 13 June 1962. (FAI)
Captain Richard H. Coan, USAF, at Mono Lake, California, 13 June 1962. (FAI)

13 June 1962: At Mono Lake, California, Captain Richard H. Coan, United States Air Force, set a  Fédération Aéronautique Internationale (FAI) World Record for Distance Over a Closed Circuit Without Landing with a specially prepared Kaman HH-43B Huskie, serial number 60-0263. With cowlings, doors and unneeded internal equipment removed—including brake lines to the rear wheels—the helicopter had an empty weight of just 5,300 pounds (2,404 kilograms).

Captain Richard H. Coan prepares to lift off aboard the HH-43B Huskie, 13 June 1962. (U.S. Air Force)
Near Mono Lake, California, Captain Richard H. Coan prepares to lift off aboard HH-43B-KA Huskie 60-0263, at dawn, 13 June 1962. (U.S. Air Force)

Flying along a 12-mile (19.3 kilometer) section of California Highway 167 (Pole Line Road) on the north shore of the lake, Captain Coan flew 27 laps in just over seven hours, until the Huskie ran out of fuel and settled to the pavement in a low-altitude autorotation. Without brakes and with the rear wheels locked, the helicopter rolled off the side of the roadway, but came to a stop before ending up in a ditch. The total distance flown was 1,055.16 kilometers (655.65 miles), a new Fédération Aéronautique Internationale (FAI) World Record for Distance Over a Closed Circuit Without Landing.¹

Kaman HH-43B Huskie 60-0263 parked at the edge of the roadway after it’s record-setting flight, at Mono Lake, California, 13 June 1962. (FAI)
Kaman HH-43B Huskie 60-0263 parked at the edge of Pole Line Road after its record-setting flight near Mono Lake, California, 13 June 1962. (FAI)

This same helicopter, flown by Captain Walter C. McMeen, set an FAI World Record for Altitude with a 1000 kilogram Payload to an altitude of 8,037 meters (26,368 feet) over Luke Air Force Base, Arizona, 25 May 1961.² On 18 October 1961, again at Bloomfield, Lieutenant Colonel Francis M. Carney set a World Record for Altitude Without Payload when he flew 60-0263 to 10,010 meters (32,841 feet).³ The following week, on 24 October 1961, Colonel Carney set six more world records, flying the HH-43B to 3,000 meters (9,853 feet) in 2 minutes, 41.5 seconds;⁴ 6,000 meters (19,685 feet) in 6 minutes 49.3 seconds;⁵ and to 9,000 meters (29,528 feet) in 14 minutes, 31 seconds.⁶ The following summer, Captain Chester R. Radcliffe, Jr., set an FAI World Record for Distance Without Landing when he flew it from Hill Air Force Base, Utah, to Springfield, Minnesota, a distance of 1,429.80 kilometers (888.44 miles), 5 July 1962.⁷

The Kaman Aircraft Corporation Huskie was used by the U.S. Air Force, U.S. Navy and Marine Corps, primarily for short range rescue operations. It was operated by two pilots and two rescue crewmen.

A turboshaft engine drove a unique system of counter-rotating and intermeshing rotors to provide lift, thrust and directional control. The counter-rotation cancelled the torque effect so no anti-torque, or tail, rotor was necessary. This allowed all of the engine’s power to drive the main rotor system.

The fuselage of the H-43B was 25 feet, 2 inches (7.671 meters) long. Each rotor had a diameter of 47 feet, 0 inches (14.326 meters). It’s height was 15 feet, 6½ inches (4.737 meters). The helicopter’s empty weight was 4,470 pounds (2,028 kilograms) and its maximum gross weight was 8,800 pounds (3,992 kilograms).****

The H-43B was powered by one Lycoming T53-L-1B turboshaft engine, rated at 860 shaft horsepower at 21,510 r.p.m. The engine uses a 5-stage axial-flow, 1 stage centrifugal-flow, compressor with a single stage gas producer turbine and single-stage power turbine. A reverse-flow combustion section allows significant reduction in the the engine’s total length. The power turbine drives the output shaft through a 3.22:1 gear reduction. The T53-L-1 is 3 feet, 11.8 inches (1.214 meters) long and 1 foot, 11.0 inches (0.584 meters) in diameter. It weighs 460 pounds (209 kilograms).

The Huskie’s economical cruise speed was 98 miles per hour (158 kilometers per hour), and the maximum speed was 120 miles per hour (193 kilometers per hour). Its hover ceiling out of ground effect (HOGE) was 18,000 feet (5,486 meters), and in ground effect (HIGE) was 20,000 feet (6,096 meters) and it had a range of 235 miles (378 kilometers). Normal rotor speed in flight was 255–260 r.p.m., with a minimum 238 r.p.m. in autorotation.

Captain Coan was awarded the Distinguished Flying Cross for the record flight. Later as a major, he commanded Detachment 8, 38th Aerospace Rescue and Recovery Squadron, at Cam Ranh Bay Air Base during the Vietnam War. He retired from the Air Force at the rank of lieutenant colonel.

With the call sign Pedro, the HH-43 was a rescue helicopter that served in combat during the Vietnam War.

The record-setting Kaman HH-43B Huskie 60-0263 was last assigned to Detachment 3, 42nd Aerospace Rescue and Recovery Squadron, Kirtland Air Force Base, New Mexico. It is in the collection of the National Museum of the United States Air Force, Wright-Patterson Air Force Base, Ohio. Its distance record still stands.

Kaman HH-43B-KA Huskie 60-0263 at the National Museum of the United States Air Force. (U.S. Air Force)
Kaman HH-43B-KA Huskie 60-0263 at the National Museum of the United States Air Force. (U.S. Air Force)

¹ FAI Record File Number 1258

² FAI Record File Number 13154

³ FAI Record File Number 1870

⁴ FAI Record File Numbers 13057 and 13135

⁵ FAI Record File Numbers 13056 and 13136

⁶ FAI Record File Number 13137

⁷ FAI Record File Number 13208

**** Maximum overload gross weight is 9,150 pounds (4,150 kilograms) at a load factor of 2.0

© 2020, Bryan R. Swopes

22 May 1958

Colonel Edward Norris LeFaivre, United States Marine Corps.

22 May 1958: At NAS Point Mugu, a naval air weapons test center on the southern California shoreline, Major Edward Norris LeFaivre, United States Marine Corps, set five Fédération Aéronautique Internationale (FAI) World Records for Time to Altitude with a Douglas F4D-1 Skyray, Bureau of Aeronautics (“Bu. No.”) serial number 130745.

Runway 21 at Point Mugu (NTD) has a slight downhill gradient and the departure end is very near the shoreline, with an elevation of just 9 feet (2.7 meters). This runway has been used for time-to-altitude records on several occasions.

Douglas F4D-1 Skyray Bu. No. 130745 at NOTS China Lake, circa 1960. (China Lake Alumni)

Major LeFaivre’s Skyray climbed from the runway to 3,000 meters (9,843 feet) in 44.392 seconds ¹; 6,000 meters (19,685 feet), 1:06.095 ²; 9,000 meters (29,528 feet), 1:30.025 ³; 12,000 meters (39,370 feet), 1:51.244 ⁴; and 15,000 meters (49,213 feet), 2:36.233.⁵ This was the first time that a 15,000 meter had been set.

F4D-1 Bu. No. 130745 was the fifth production Skyray. The Douglas Aircraft Company F4D-1 Skyray was a single-place, single-engine, transonic all-weather interceptor, designed to operated from the United States Navy’s aircraft carriers. It had a tailless delta configuration with rounded wing tips. The Skyray was 45 feet, 7-7/8 inches (13.916 meters) long, with a wingspan of 33 feet, 6 inches (10.211 meters) and height of 12 feet, 11-7/8 inches (3.959 meters). The span with wings folded for storage on flight and hangar decks was 26 feet, 1-7/8 inches (7.972 meters), The wings’ leading edges were swept aft 52.5°. The total wing area was 557 square feet (51.747 square meters).

The interceptor had an empty weight of 16,024 pounds (7,268 kilograms) and maximum weight of 28,000 pounds (12,701 kilograms).

Early production F4D-1s were powered by a Pratt & Whitney J57-P-8 engine. The J57 was a two-spool axial-flow turbojet which had a 16-stage compressor section (9 low- and 7 high-pressure stages) and a 3-stage turbine (1 high- and 2 low-pressure stages). The J57-P-8 had a normal power rating of 8,700 pounds of thrust (38.70 kilonewtons) at 5,750 r.p.m. , N1. The military power rating was 10,200 pounds of thrust (45.37 kilonewtons) at 6,050 r.p.m., N1. Maximum power was 14,500 pounds of thrust (64.50 kilonewtons) at 6,050 r.p.m., N1, with afterburner. The engine was 3 feet, 4.5 inches (1.029 meters) in diameter, 20 feet, 10 inches (6.35 meters) long.

The cruise speed of the F4D-1 was 520 miles per hour (837 kilometers per hour). Its maximum speed was 722 miles per hour (1,162 kilometers per hour, or 0.95 Mach) at Sea Level, and 695 miles per hour (1,118 kilometers, or Mach 1.05) at 36,000 feet (10,973 meters). The Skyray had a service ceiling of 55,000 feet (16,764 meters), and maximum range of 1,200 miles (1,931 kilometers).

The F4D-1 was armed with four 20 mm Colt Mark 12 autocannon with 70 rounds per gun. The Mark 12 had a rate of fire of 1,000 rounds per minute. Four AAM-N-7 (AIM-9) Sidewinder infrared-homing air to air missiles could be carried under the wings, or various combinations of 2.75 inch rocket pods, up to a maximum of 76 rockets.

A U.S. Marine Corps Douglas F4D-1 Skyray, Bu. No. 134815, assigned to VMF(AW)-115, just south of the Palos Verdes Peninsula of Southern California, 4 April 1957. (Robert L. Lawson Collection, National Naval Aviation Museum)

The Skyray had very unpleasant handling characteristics. It was used to teach pilots how to handle unstable aircraft. Bu. No. 130745 was used as a flight test aircraft at NOTS China Lake, a Naval Ordnance Test Station near Ridgecrest, in the high desert of southern California. (China Lake, NID, is about 55 miles/89 kilometers north-northwest of Edwards AFB, EDW).

Lt. Jan M. Graves, USNR

On 21 October 1960, Lieutenant Jan Michael (“Black Jack”) Graves, United States Naval Reserve, was flying 130745, simulating aircraft carrier takeoffs from Runway 21 at China Lake. The F4D-1 had just taken off when, at approximately 100 feet (30.5 meters), it slowly rolled upside down and then crashed on to the runway. It slid about 1.14 miles (1.83 kilometers) before coming to  stop. Lieutenant Graves was killed.

Accident investigators found that a broken wire in the rudder feedback system had allowed the rudder to go to its maximum deflection.

As this Douglas F4D-1 Skyray dives away from the camera, its unusual delta wing planform can be seen. (United States Navy)

Edward Norris LeFaivre was born at Baltimore, Maryland, 11 October 1924. He attended the University of Maryland, graduating with a Bachelor of Science Degree. He was then employed at the Glenn L. Martin Company.

LeFaivre joined the United States Marine Corps in 1942. Trained as a Naval Aviator, he was assigned as a night fighter pilot with VMF(N)-533 at Yontan, Airfield, Okinawa. On 18 May 1945, Lieutenant LeFaivre shot down two enemy bombers with his Grumman F6F-5N Hellcat, for which he was awarded the Silver Star.

Captain LeFaivre continued as a night fighter pilot during the Korean War. Flying a Grumman F7F Tigercat assigned to VMF(AW)-513, on 21 October 1951, he repeatedly attacked a heavy concentration of enemy vehicles, LeFaivre’s airplane was shot down. He was rescued by helicopter, but his observer was listed as missing in action. Captain LeFaivre was awarded two additional Silver Stars for his actions on that night.

From 8 August to 31 December 1967, Colonel LeFaivre commanded Marine Air Group 13 (MAG-13), based at Chu Lai Air Base, Republic of South Vietnam. The group’s three squadrons were equipped with the McDonnell F-4B Phantom II.

Colonel Edward Norris LeFaivre retired from the Marine Corps in 1972. He died 28 June 1992 at the age of 68 years, and was buried at the Arlington National Cemetery, Arlington, Virginia.

¹ FAI Record File Number 8591

² FAI Record File Number 8592

³ FAI Record File Number 8593

⁴ FAI Record File Number 8594

⁵ FAI Record File Number 8595

© 2018, Bryan R. Swopes