Tag Archives: Aircraft Accident

26 February 1955

Aviation, , , , , , , , ,
North American Aviation production test pilot George Franklin Smith with a North American F-100A Super Sabre (NASM)

26 February 1955: Although it was his day off, North American Aviation production test pilot George Franklin Smith stopped by the office at Los Angeles Airport (today, known as Los Angeles International airport, or simply “LAX”, its FAA airport identifier). The company’s flight  dispatcher told him that a brand-new F-100A-20-NA Super Sabre, serial number 53-1659, was sitting on the flight line and needed to be test flown before being turned over to the Air Force.

North American Aviation production test pilot George F. Smith (left) walks away from an F-100 Super Sabre. (Photograph courtesy of Neil Corbett, Test and Research Pilots, Flight Test Engineeers)
North American Aviation production test pilot George F. Smith (left) walks away from an F-100 Super Sabre. (Photograph courtesy of Neil Corbett, Test and Research Pilots, Flight Test Engineeers)

Smith was happy to take the flight. He departed LAX in full afterburner and headed off shore, climbing to 35,000 feet (10,668 meters) over the Pacific Ocean to start the test sequence.

A North American F-100A-1-NA Super Sabre, 52-5757 (the second production airplane) takes off at Los Angeles International Airport. (This airplane, flown by NAA test pilot Bob Hoover, crashed east of Palmdale, California, 7 July 1955, when he could not recover from a flat spin. Hoover safely ejected but the Super Sabre was destroyed.) (North American Aviation, Inc.)

But it was quickly apparent that something was wrong: The flight controls were heavy, and then there was a hydraulic system failure that caused the Super Sabre pitch down into a dive. Smith couldn’t pull it out of the dive and the airplane’s speed rapidly increased, eventually passing Mach 1.

Smith was unable to regain control of the F-100. He had no choice but to bail out. As he ejected, Smith read the instruments: the Mach meter indicated Mach 1.05—785 miles per hour (1,263 kilometers per hour)—and the altitude was only 6,500 feet (1,981 meters).

George F. Smith recovering in hospital after his supersonic ejection. (Getty Images)
Smith recovering in hospital after his supersonic ejection. (Getty Images)

The force of the wind blast hitting him as he came out of the cockpit knocked him unconscious. Estimates are that he was subjected to a 40 G deceleration. His parachute opened automatically and he came down approximately one-half mile off Laguna Beach. Fortunately he hit the water very close to a fishing boat crewed by a former U.S. Navy rescue expert.

The F-100 dived into the Pacific Ocean approximately ¼-mile (0.4 kilometers) offshore between Dana Point and Laguna Beach.

George Smith was unconscious for six days, and when he awoke he was blind in both eyes. After four surgeries and seven months in the hospital, he recovered from his supersonic ejection and returned to flight status.

North American Aviation, Inc. F-100A-20-NA Supre Sabre 53-1646. This fighter is from the same production block as the Super Sabre flown by George F. Smith, 53-1659, 26 February 1955. (Unattributed)

George F. Smith appears in this brief U.S. Air Force informational film:

The North American Aviation F-100 Super Sabre was designed as a supersonic day fighter. Initially intended as an improved F-86D and F-86E, it soon developed into an almost completely new airplane. The fuselage incorporated the “area rule,” a narrowing in the fuselage width at the wings to increase transonic performance, similar to the Convair F-102A.

The Super Sabre had a 49° 2′ sweep to the leading edges of the wings and horizontal stabilizer. The ailerons were placed inboard on the wings and there were no flaps, resulting in a high stall speed in landing configuration. The horizontal stabilizer was moved to the bottom of the fuselage to keep it out of the turbulence created by the wings at high angles of attack. The F-100A had longer wings and a distinctively shorter vertical fin than the YF-100A. The upper segment of the vertical fin was swept 49° 43′.

North American Aviation YF-100A Super Sabre 52-5754 lands on the dry lake at Edwards Air Force Base, California. (North American Aviation, Inc.)

There were two service test prototypes, designated YF-100A, followed by the production F-100A series. The first ten production aircraft (all of the Block 1 variants) were used in the flight testing program.

The F-100A Super Sabre was 47 feet, 1¼ inches (14.357 meters) long with a wingspan of 36 feet, 6 inches (11.125 meters). With the shorter vertical fin than the YF-100A, the initial F-100As had an overall height of 13 feet, 4 inches (4.064 meters), 11 inches (27.9 centimeters) less than the YF-100A.

The F-100A had an empty weight of 18,135 pounds (8,226 kilograms), and gross weight of 28,899 pounds (13,108 kilograms). Maximum takeoff weight was 35,600 pounds (16,148 kilograms). It had an internal fuel capacity of 755 gallons (2,858 liters) and could carry two 275 gallon (1,041 liter) external fuel tanks.

Following North American Aviation test pilot George Welch’s fatal accident, 12 October 1954, NACA designed a new vertical fin for the F-100A. It was taller but also had a longer chord. This resulted in a 10% increase in area. (NASA E-1573)

The early F-100As were powered by a Pratt & Whitney Turbo Wasp J57-P-7 afterburning turbojet engine. It was rated at 9,700 pounds of thrust (43.148 kilonewtons) for takeoff, and 14,800 pounds (65.834 kilonewtons) with afterburner. Later production aircraft used a J57-P-39 engine. The J57 was a two-spool axial flow turbojet which had a 16-stage compressor, and a 3-stage turbine. (Both had high- and low-pressure stages.) The engine was 15 feet, 3.5 inches (4.661 meters) long, 3 feet, 5.0 inches (1.041 meters) in diameter, and weighed 4,390 pounds (1,991 kilograms).

Test Pilot A. Scott Crossfield flew this F-100A-5-NA, 52-5778, in flight testing at the NACA High Speed Flight Station, October–December 1954. (NASA)

The Super Sabre was the first U.S. Air Force fighter capable of supersonic speed in level flight. It could reach 760 miles per hour (1,223 kilometers) at Sea Level. (Mach 1 is 761.1 miles per hour, 1,224.9 kilometers per hour, under standard atmospheric conditions.) Its maximum speed was 852 miles per hour (1,371 kilometers per hour) at 35,000 feet (10,668 meters)—Mach 1.29. The service ceiling was 44,900 feet (13,686 meters). Maximum range with external fuel was 1,489 miles (2,396 kilometers).

The F-100 was armed with four M-39 20 mm autocannons, capable of firing at a rate of 1,500 rounds per minute. The ammunition capacity of the F-100 was 200 rounds per gun.

North American Aviation built 199 F-100A Super Sabres at its Inglewood, California, plant before production shifted to the F-100C fighter bomber variant. Approximately 25% of all F-100As were lost in accidents.

This is the fifth production F-100A-1-NA Super Sabre, 52-5760, in flight southeast of San Bernardino, California. In this photograph, FW-760 has the taller vertical fin that was designed to improve the Super Sabre’s controllability. (U.S. Air Force)

© 2019, Bryan R. Swopes

24 February 1989

Aviation, , , , , , , , , , , ,
United Air Lines' Boeing 747 N4713U, photographed at Los Angeles International Airport, 14 April 1982. (Ted Quackenbush via Wikipedia)
United Airlines’ Boeing 747-122 s/n 19875, N4713U, photographed at Los Angeles International Airport, 14 April 1982. (Ted Quackenbush via Wikipedia)

24 February 1989: At 01:52:49 HST, United Airlines Flight 811 was cleared for takeoff from Honolulu International Airport (HNL), enroute to Auckland International Airport (AKL) and onward to Sydney, Australia (SYD). On board were 337 passengers and 18 crew members. The airliner was under the command of Captain David Cronin, with First Officer Gregory Slader and Second Officer Randal Thomas. The airliner was a Boeing 747-122, serial number 19875, registered N4713U.

16 minutes after takeoff, about 60 miles (97 kilometers) south of Honolulu, the 747 was climbing through an altitude of 22,000 feet (6,705 meters) at 300 knots (345 miles per hour/556 kilometers per hour) when, at 02:09:09 HST, the cargo door on the lower right side of the fuselage, just forward of the wing, failed, blowing outward. Explosive decompression blew a huge hole in the fuselage. Ten passenger seats were carried away along with nine passengers. A flight attendant was nearly lost, but was dragged back inside by passengers and crew.

The damaaged fuselage of United Airlines Flight 811. (BBC)

Debris damaged the two engines on the right wing, causing them to lose power. Flames were visible. Both engines had to be shut down. Flight 811 declared an emergency, began descending and dumping fuel to reduce the airliner’s weight for an emergency landing. The 747 turned back toward Honolulu.

Because the wing had also been damaged, the flaps could not be fully extended and this required a much higher than normal approach speed. The 747 touched down at approximately 200 knots (230 miles per hour/370 kilometers per hour). After coming to a stop, Flight 811 was completely evacuated within 45 seconds. Every flight attendant suffered some injury.

Damaged forward fuselage of N4713U. (Paul Sakuma/AP)

The cause of the cargo door failure was determined to be a faulty design, combined with a short in the 747’s electrical system. The door was recovered by a U.S. Navy deep sea submersible from a depth of 14,100 feet (4,298 meters).

United Airlines’ Boeing 747 N4713U was repaired and returned to service. It was re-registered N4724U. チャーリーマイクさん

N4713U made its first flight 20 October 1970 and had accumulated 58,814:24 flight hours  and 15,027 cycles prior to takeoff from Honolulu. It was repaired at a cost of $14,000,000 and then returned to service, re-registered N4724U. In 1997, 19875 was sold to Air Dabia and assigned registration C5-FBS. It has since been scrapped.

Air Dabia Boeing 747-100 C5-FBS, photographed January 1998. (Aero Icarus)

The 747-100 series was the first version of the Boeing 747 to be built. It was operated by a flight crew of three and was designed to carry 366 to 452 passengers. It is 231 feet, 10.2 inches (70.668 meters) long with a wingspan of 195 feet, 8 inches (59.639 meters) and overall height of 63 feet, 5 inches (19.329 meters). The interior cabin width is 20 feet (6.096 meters), giving it the name “wide body.” Its empty weight is 370,816 pounds (168,199 kilograms) and the Maximum Takeoff Weight (MTOW) is 735,000 pounds (333,390 kilograms).

The 747-100 is powered by four Pratt & Whitney JT9D-7A high-bypass ratio turbofan engines. The JT9D is a two-spool, axial-flow turbofan engine with a single-stage fan section, 14-stage compressor (11 high- and 3 low-pressure stages) and 6-stage turbine (2 high- and 4 low-pressure stages). The engine is rated at 46,950 pounds of thrust (208.844 kilonewtons), or 48,570 pounds (216.050 kilonewtons) with water injection (2½-minute limit). This engine has a maximum diameter of 7 feet, 11.6 inches (2.428 meters), is 12 feet, 10.2 inches (3.917 meters) long and weighs 8,850 pounds (4,014 kilograms).

The 747-100 has a cruise speed of 0.84 Mach (555 miles per hour, 893 kilometers per hour) at 35,000 feet (10,668 meters). The maximum certificated operating speed is 0.92 Mach. The airliner’s maximum range is 6,100 miles (9,817 kilometers).

The Boeing 747 has been in production for 48 years. More than 1,520 have been delivered to date. 205 of these were the 747-100 series. The U.S. Air Force has selected the Boeing 747-8 as the next presidential transport aircraft.

Captain David M. Cronin died 6 October 2010 at the age of 81 years.

A surprisingly poor quality image showing teh damage to Boeing 747 N4713U resulting from the failure of the cargo door. (Unattributed)
A surprisingly poor quality image showing the damage to Boeing 747 N4713U resulting from the failure of the cargo door. (Unattributed)

© 2019, Bryan R. Swopes

19 February 1985

Aviation, , , , , , , , , , , ,
China Airlines' Boeing 747SP, N45522V. Thi saircraft few as Dynasty 006, 18 February 1985. (Andrew Hunt)
China Airlines’ Boeing 747SP, N4522V. This aircraft few as Dynasty 006, 18 February 1985. (Andrew Hunt)

19 February 1985: At 10:16 a.m., Pacific Standard Time, while enroute from Taipei, Republic of China, to Los Angeles, California, China Airlines’ Flight 006 (call sign “Dynasty Six”), a Boeing 747SP-09, FAA registration N4522V, was cruising at 41,000 feet (12,497 meters), 300 nautical miles (556 kilometers) northwest of San Francisco, California. It had a crew of 23 with 251 passengers. The airliner had a flight crew of five under command of Captain Min-Yuan Ho, with a co-pilot and flight engineer, as well as a relief captain and flight engineer, due to the length of the trans-Pacific flight.

Captain Min-Yuan Ho, describing the incident to reporters at San Francisco Airport, 19 February 1985.
Captain Min-Yuan Ho, describing the incident to reporters at San Francisco Airport, 19 February 1985.

The Number 4 engine, the outboard engine on the airplane’s right wing, a Pratt & Whitney JT9D-7A turbofan, refused to respond with the other engines as the throttles were advanced, and it “hung” and remained at a low power level. It did not flame out, as the crew believed. The crew attempted restart procedures, however they did so incorrectly.

The airliner’s autopilot was engaged and the aircraft began to yaw and bank because of the asymmetric thrust. The copilot, First Officer Ju Yu Chang, used full opposite aileron to stop the roll, but neither pilot or copilot applied any rudder inputs to correct the yaw. (It was later determined that they believed, incorrectly, that the autopilot controlled rudder position.)

The airplane departed controlled flight, rolled over and dived. It lost 30,000 feet (9,144 meters) of altitude before the crew was able to recover, however the airplane was severely damaged, with bent wings, a damaged left aileron, lost parts of its elevators and horizontal stabilizers and damaged landing gear doors. It had experienced acceleration forces as high as 4.8 Gs as it descended through 30,552 feet (9,312 meters) and a peak 5.1 Gs at 19,083 feet (5,816 meters).

This illustration, based on the NTSB accident investigation, shows the various attitudes of China Airlines Flight 006 as it descended out of control, 19 February 1985. (Wikipedia)
This illustration, based on the NTSB accident investigation, shows the various attitudes of China Airlines Flight 006 as it descended out of control, 19 February 1985. (Wikipedia)

Of the 287 persons on board, 24 were injured. Two were seriously hurt and the flight diverted to San Francisco. The 747SP was substantially damaged. It was nearly two years before repairs completed.

China Airlines’ Boeing 747SP-09 N4522V, photographed at Amsterdam, 16 June 1991. (Torsten Maiwald/Wikimedia)

The National Transportation Safety Board investigation made the following findings:

3.1 Findings

1. The flightcrew was properly certificated and qualified.

2. The changing airspeeds encountered by Flight 006 and the resultant compensating throttle adjustments were caused by wind speed variations.

3. The No. 4 engine did not flame out, but “hung” at about 1.0 EPR.

4. During his attempt to recover the No. 4 engine, the flight engineer did not close the bleed air valve switch before advancing the No. 4 throttle.

5. The other three engines did not lose thrust nor did they flame out.

6. The captain did not disengage the autopilot in a timely manner after thrust was lost on the No. 4 engine. The autopilot effectively masked the approaching onset of the loss of control of the airplane.

7. The captain was distracted from his flight monitoring duties by his participation with the flight engineer in the evaluation of the No. 4 engine’s malfunction.

8. With the exception of the loss of thrust on the No. 4 engine, no other airplane malfunction affected the performance of the airplane; the loss of thrust on the No. 4 engine did not contribute to the accident.

9. The captain was also distracted by his attempts to arrest the airplane’s decreasing airspeed, and this also contributed to his failure to detect the airplane’s increasing bank angle.

10. The lateral control deflections required to maintain level flight under conditions of thrust asymmetry and decreasing airspeed exceeded the limits of the autopilot’s lateral control authority, causing the airplane to roll and yaw to the right. The captain lost control of the airplane when, after disengaging the autopilot, he failed to make the proper flight control corrections to recover the airplane.

11. The damage to the airplane was a result of the acceleration forces and high airspeeds that occurred during the upset and recovery maneuvers.

3.2 Probable Cause

The National Transportation Safety Board determines that the probable cause of this accident was the captain’s preoccupation with an inflight malfunction and his failure to monitor properly the airplane’s flight instruments which resulted in his losing control of the airplane.

Contributing to the accident was the captain’s over-reliance on the autopilot after the loss of thrust on the No. 4 engine.

The captain had not slept during his previous rest period and his tiredness was considered a factor in this incident.

Damage to the tail surfaces of Boeing 747SP N4522V.
Damage to the tail surfaces of Boeing 747SP N4522V.

The Boeing 747SP (“Special Performance”) is a very long range variant of the 747-100 series airliners. It has a shorter fuselage and larger tail surface than the standard model. The weight savings allows it to carry more fuel for longer flights, and it is also faster. Boeing built 45 747SPs.

The 747SP is 184 feet, 9 inches (56.312 meters) long, with a wingspan of 195 feet, 8 inches (59.639 meters). It has an overall height of 65 feet, 10 inches (20.066 meters). It has a maximum takeoff weight of 670,000 pounds.

The airliner has a cruising speed of 0.88 Mach (616 miles per hour, or 991 kilometers per hour) and a maximum speed of 0.92 Mach (680 knots, 1,094 kilometers per hour). The service ceiling is 45,100 feet (13,746 meters) and the range is 7,650 miles (12,311 kilometers), carrying 276 passengers and baggage. The fuel capacity is 47,210 gallons. (178,709 liters).

Damaged horizontal stabilizer and elevators of Boeing 747SP-09 N4522V (NTSB)

Boeing 747 SP N4522V (serial number 22805, line number 564) made its first flight 10 June 1982. It was leased to China Airlines by the Wilmington Trust Company, 15 June 1982 and delivered 29 June 1982.

Following the Flight 006 incident, the airliner was repaired by Boeing and returned to service 25 April 1985. It was leased to Mandarin Airlines from 1 January 1997 to 31 December 1997, then placed in storage at Las Vegas, Nevada.

On 18 December 2001, N4522V was purchased by Global Peace Initiative Inc. The FAA suspended its operating certificate 18 July 2005 for lack of proper maintenance. The airplane has been stored at Tijuana International Airport (TIJ), just south of the U.S./Mexico border, since 16 December 2005.

The FAA registration of N4522V expired 31 December 2016.

Boeing 747SP 09 serial number 22805. The airliner’s U.S. registration expired 31 December 2016. (Global Peace Initiative)
Boeing 747SP 09 serial number 22805. The airliner’s U.S. registration expired 31 December 2016. The derelict airliner was photographed at Tijuana, 16 June 2019. (Jorge Perez)

© 2021, Bryan R. Swopes

18 February 1943, 12:26 p.m., Pacific War Time

Aviation, , , , , , , , , , , ,
The second prototype Boeing XB-29 Superfortress, 41-0003, takes off from Boeing Field, 12:09 p.m., 18 February 1943. (Boeing)
The second prototype Boeing XB-29 Superfortress, 41-0003, takes off from Boeing Field, 12:09 p.m., 18 February 1943. (Boeing)

18 February 1943: At 12:09 p.m., Boeing Aircraft Company Chief Test Pilot Edmund Turney (“Eddie”) Allen took off from Boeing Field, Seattle, Washington, in the Number 2 prototype XB-29 Superfortress long-range heavy bomber, serial number 41-0003. Allen’s co-pilot was engineering test pilot Robert R. Dansfield. The rest of the XB-29 flight crew were Charles Edmund Blaine, flight test engineer; Fritz Mohn, senior inspector; Vincent W. North, aerodynamicist; Harry William Ralston, radio operator; Barclay J. Henshaw, flight test analyst; Thomas R. Lankford, engineer; Robert Willis Maxfield, flight test engineer; Raymond Louis Basel, flight test engineer; Edward I. Wersebe, flight test engineer.

Edmund T. ("Eddie") Allen. (San Diego Air and Space Museum Archive)
Edmund Turney Allen. (San Diego Air & Space Museum Archive)

41-0003 had first flown on 30 December 1942, piloted by Allen. During that flight, the prototype bomber suffered a major engine fire and Eddie Allen’s performance in returning the airplane to the airport later earned him the U.S. Army’s Air Medal, awarded on the specific orders of President Harry S. Truman.

Problems with the XB-29s’ Wright R-3350-13 engines had caused major delays in the B-29 testing program. The Number 2 aircraft had its engines replaced with those from the first XB-29, 41-0002. By 18 February, 41-0003 had made only eight flights, with a total flight time of 7 hours, 27 minutes.

The ninth test flight of 41-0003 was planned to test the climb performance to 25,000 feet (7,620 meters) and to collect engine cooling data.

At 12:17 p.m., 41-0003 was climbing through 5,000 feet (1,524 meters) when the #1 engine (the outboard engine on the left wing) caught fire. The engine was shut down and CO2 fire extinguishers were activated. Eddie Allen began a descent and turned back toward Boeing Field.

The wind was out of the south at 5 miles per hour (2.24 meters per second) so it was decided to land on Runway 13, the southeast/northwest runway. At 12:24, radio operator Harry Ralston reported that the XB-29 was 4 miles (6.4 kilometers) northeast of the field at 1,200 feet (366 meters).

The airplane was in the landing pattern turning from the downwind leg to the base leg when at 12:25 an explosion occurred. Ralston was heard to say, “Allen, better get this thing down in a hurry. The wing spar is burning badly.”

In order to save weight, various parts of the Wright R-3350 engine were made of magnesium, a flammable metal which burned at a very high temperature. With an engine on fire, the bomber’s wing structure was extremely vulnerable.

The prototype bomber was now shedding parts and left a trail behind it on the ground. The fire was now burning inside the fuselage. Three crew members bailed out but the altitude was too low and they were killed.

At 12:26 p.m., Boeing XB-29 41-0003 crashed into the Frye Meat Packing Plant, south of downtown Seattle, and exploded. Nearly 5,000 gallons (18,927 liters) of gasoline started a massive fire. The 8 men still aboard the prototype bomber were killed, as were 20 employees inside the building. A firefighter who responded was also killed.

The Frye packing plant on fire, 18 February 1943. (Seattle Post-Intelligencer)

Three XB-29 prototypes were built. The XB-29 was 98 feet, 2 inches (29.896 meters) long with a wing span of 141 feet, 3 inches (43.053 meters), and 27 feet, 9 inches (8.458 meters) high to the top of its vertical fin. The prototype bomber had a gross weight of 105,000 pounds (47,627.2 kilograms).

Boeing XB-29-BO, 41-002, the first XB-29 built. (U.S. Air Force)
Boeing XB-29-BO, 41-002, the first XB-29 built. (U.S. Air Force)

The XB-29 was powered by four 3,347.662-cubic-inch-displacement (54.858 liter) air-cooled, supercharged, Wright Aeronautical Division Cyclone 18 670C18H1 (R-3350-13) two-row 18-cylinder radial engines (also known as the Duplex-Cyclone) with a compression ratio of 6.85:1. The R-3350-13 had a Normal Power rating of 2,000 horsepower at 2,400 r.p.m., and 2,200 horsepower at 2,800 r.p.m. for takeoff, using 100 octane aviation gasoline. The engines turned 17-foot-diameter (5.182 meters) three-bladed Hamilton Standard Hydromatic constant-speed propellers through a 0.35:1 gear reduction. The R-3350-13 was 76.26 inches (1.937 meters) long, 55.78 inches (1.417 meters) in diameter, and weighed 2,668 pounds (1,210 kilograms).

The XB-29 had a maximum speed of 368 miles per hour (592 kilometers per hour) and cruised at 255 miles per hour (410 kilometers per hour). Its service ceiling was 32,100 feet (9,784 meters). The airplane was designed to carry 20,000 pounds (9,072 kilograms) of bombs.

The B-29 Superfortress was the most technologically advanced—and complex—aircraft of the War. It required the manufacturing capabilities of the entire nation to produce. Over 1,400,000 engineering man-hours had been required to design the prototypes. It would be manufactured by Boeing at Seattle and Renton, Washington and at Wichita, Kansas; by Glenn L. Martin Company at Omaha, Nebraska; and by Bell Aircraft Corporation, Atlanta, Georgia.

There were three XB-29 prototypes; 14 YB-29 pre-production test aircraft; 2,513 B-29; 1,119 B-29A; and 311 B-29B Superfortress aircraft. The bomber served during World War II and the Korean War and continued in active U.S. service until 1960.

The Eddie Allen.

The employees of the Boeing plant at Wichita, Kansas donated the money to build a B-29 to be named in honor of Eddie Allen. B-29-40-BW 42-24579 flew 24 combat missions. On its final mission over Tokyo, Japan, the Eddie Allen was so badly damaged that, though it was able to reach its base on the island of Tinian, it never flew again.

Boeing B-29 Superfortress "Eddie Allen." (U.S. Air Force)
Boeing Wichita-built B-29-40-BW Superfortress 42-24579, “Eddie Allen,” of the 45th Bombardment Squadron (Very Heavy), 40th Bombardment Group (Very Heavy), XX Bomber Command, circa 1944. (U.S. Air Force)
Boeing's acknoledgemnt of the sacrifice of its flight test crew, 18 February 1943,
Boeing’s acknowledgement of the sacrifice of its flight test crew, 18 February 1943, from the annual report to the shareholders.

© 2019, Bryan R. Swopes

17 February 1956

Aviation, , , , , , , , , , , , , ,
Lockheed YF-104A, 55-2955. (AFFTC History Office)

17 February 1956: Test pilot Herman Richard (“Fish”) Salmon made the first flight of the Lockheed YF-104A service test prototype, Air Force serial number 55-2955 (Lockheed serial number 183-1001). This airplane, the first of seventeen pre-production YF-104As, incorporated many improvements over the XF-104 prototype, the most visible being a longer fuselage.

Lockheed test pilots Anthony W. (“Tony”) LeVier, on the left, and Herman R. (“Fish”) Salmon, circa 1957. An F-104 Starfighter is in the background. (Jet Pilot Overseas)

On 28 February 1956, YF-104A 55-2955 became the first aircraft to reach Mach 2 in level flight.

The YF-104A was later converted to the production standard and redesignated F-104A.

Lockheed XF-104 53-7786. (Lockheed-Martin)
Lockheed YF-104A Starfighter 55-2955 (183-1001), right profile. Note the increased length of the fuselage and revised air intakes, compared to the XF-104, above. Also, the XF-104’s nose gear retracts backward, while the YF-104A’s gear swings forward. (U.S. Air Force)

The Lockheed F-104A Starfighter is a single-place, single-engine, Mach 2 interceptor. It was designed by a team lead by the legendary Clarence L. “Kelly” Johnson. The F-104A is 54.77 feet (16.694 meters) long with a wingspan of 21.94 feet (6.687 meters) and overall height of 13.49 feet (4.112 meters). The total wing area is just 196.1 square feet (18.2 square meters). At 25% chord, the wings are swept aft 18° 6′. They have 0° angle of incidence and no twist. The airplane has a very pronounced -10° anhedral. An all-flying stabilator is placed at the top of the airplane’s vertical fin, creating a “T-tail” configuration.

The F-104A had an empty weight of 13,184 pounds (5,980.2 kilograms). The airplane’s gross weight varied from 19,600 pounds to 25,300 pounds, depending on the load of missiles and/or external fuel tanks.

Internal fuel capacity was 896 gallons (3,392 liters). With Sidewinder missiles, the F-104A could carry two external fuel tanks on underwing pylons, for an additional 400 gallons (1,514 liters). If no missiles were carried, two more tanks could be attached to the wing tips, adding another 330 gallons (1,249 liters) of fuel.

Lockheed F-104A Starfighter three-view illustration with dimensions. (Lockheed Martin)

The F-104A was powered by a single General Electric J79-GE-3B, -11A or -19 engine. The J79 is a single-spool, axial-flow, afterburning turbojet, which used a 17-stage compressor and 3-stage turbine. The J79GE-3B has a continuous power rating of 8,950 pounds of thrust (39.81 kilonewtons) at 7,460 r.p.m. Its Military Power rating is 9,600 pounds (42.70 kilonewtons) (30-minute limit), and 15,000 pounds (66.72 kilonewtons) with afterburner (5-minute limit). The engine is 17 feet, 3.2 inches (5.263 meters) long, 2 feet, 8.6 inches (0.828 meters) in diameter, and weighs 3,225 pounds (1,463 kilograms).

Lockheed F-104A-5-LO Starfighter 56-742, with a General Electric J79 turbojet engine, circa 1957–59. (U.S. Air Force)

The F-104A had a maximum speed of  1,150 knots (1,323 miles per hour/2,130 kilometers per hour) at 35,000 feet (10,668 meters). The Starfighter’s initial rate of climb was 60,395 feet per minute (306.8 meters per second) and its service ceiling was 59,600 feet (18,166 meters).

The Lockheed F-104 was armed with an electrically-powered General Electric T-171E-3 (later designated M61) Vulcan 6-barrel rotary cannon, or “Gatling Gun.” The technician has a belt of linked 20 mm cannon shells. (SDASM)

Armament was one General Electric M61 Vulcan six-barreled revolving cannon with 725 rounds of 20 mm ammunition, firing at a rate of 4,000 rounds per minute. An AIM-9B Sidewinder infrared-homing air-to-air missile could be carried on each wing tip.

Lockheed YF-104A 55-2955 with landing gear retracting. (Lockheed Martin via International F-104 Society)

Lockheed built 153 of the F-104A Starfighter initial production version. A total of 2,578 F-104s of all variants were produced by Lockheed and its licensees, Canadair, Fiat, Fokker, MBB, Messerschmitt,  Mitsubishi and SABCA. By 1969, the F-104A had been retired from service. The last Starfighter, an Aeritalia-built F-104S ASA/M of the  Aeronautica Militare Italiana, was retired in October 2004.

While conducting flame-out tests in 55-2955, 25 April 1957, Lockheed  engineering test pilot John A. (“Jack”) Simpson, Jr., made a hard landing  at Air Force Plant 42, Palmdale, California, about 22 miles (35 kilometers) southwest of Edwards Air Force Base. After a bounce, the landing gear collapsed, and the Starfighter skidded off the runway. 55-2955, nick-named Apple Knocker, was damaged beyond repair. “Suitcase” Simpson was not hurt.

Lockheed F-104A 55-2955 was damaged beyond repair, 25 April 1967. (U.S. Air Force photograph via International F-104 Society)

© 2019, Bryan R. Swopes