Tag Archives: World Record for Time to Climb to a Height of 9000 Meters

13 June 1962

Aviation, , , , , , , , , , , , , , , ,
Captain Richard H. Coan, USAF, at Mono Lake, California, 13 June 1962. (FAI)
Captain Richard H. Coan, USAF, at Mono Lake, California, 13 June 1962. (FAI)

13 June 1962: At Mono Lake, California, Captain Richard H. Coan, United States Air Force, set a  Fédération Aéronautique Internationale (FAI) World Record for Distance Over a Closed Circuit Without Landing with a specially prepared Kaman HH-43B Huskie, serial number 60-0263. With cowlings, doors and unneeded internal equipment removed—including brake lines to the rear wheels—the helicopter had an empty weight of just 5,300 pounds (2,404 kilograms).

Captain Richard H. Coan prepares to lift off aboard the HH-43B Huskie, 13 June 1962. (U.S. Air Force)
Near Mono Lake, California, Captain Richard H. Coan prepares to lift off aboard HH-43B-KA Huskie 60-0263, at dawn, 13 June 1962. (U.S. Air Force)

Flying along a 12-mile (19.3 kilometer) section of California Highway 167 (Pole Line Road) on the north shore of the lake, Captain Coan flew 27 laps in just over seven hours, until the Huskie ran out of fuel and settled to the pavement in a low-altitude autorotation. Without brakes and with the rear wheels locked, the helicopter rolled off the side of the roadway, but came to a stop before ending up in a ditch. The total distance flown was 1,055.16 kilometers (655.65 miles), a new Fédération Aéronautique Internationale (FAI) World Record for Distance Over a Closed Circuit Without Landing.¹

Kaman HH-43B Huskie 60-0263 parked at the edge of the roadway after it’s record-setting flight, at Mono Lake, California, 13 June 1962. (FAI)
Kaman HH-43B Huskie 60-0263 parked at the edge of Pole Line Road after its record-setting flight near Mono Lake, California, 13 June 1962. (FAI)

This same helicopter, flown by Captain Walter C. McMeen, set an FAI World Record for Altitude with a 1000 kilogram Payload to an altitude of 8,037 meters (26,368 feet) over Luke Air Force Base, Arizona, 25 May 1961.² On 18 October 1961, again at Bloomfield, Lieutenant Colonel Francis M. Carney set a World Record for Altitude Without Payload when he flew 60-0263 to 10,010 meters (32,841 feet).³ The following week, on 24 October 1961, Colonel Carney set six more world records, flying the HH-43B to 3,000 meters (9,853 feet) in 2 minutes, 41.5 seconds;⁴ 6,000 meters (19,685 feet) in 6 minutes 49.3 seconds;⁵ and to 9,000 meters (29,528 feet) in 14 minutes, 31 seconds.⁶ The following summer, Captain Chester R. Radcliffe, Jr., set an FAI World Record for Distance Without Landing when he flew it from Hill Air Force Base, Utah, to Springfield, Minnesota, a distance of 1,429.80 kilometers (888.44 miles), 5 July 1962.⁷

The Kaman Aircraft Corporation Huskie was used by the U.S. Air Force, U.S. Navy and Marine Corps, primarily for short range rescue operations. It was operated by two pilots and two rescue crewmen.

A turboshaft engine drove a unique system of counter-rotating and intermeshing rotors to provide lift, thrust and directional control. The counter-rotation cancelled the torque effect so no anti-torque, or tail, rotor was necessary. This allowed all of the engine’s power to drive the main rotor system.

The fuselage of the H-43B was 25 feet, 2 inches (7.671 meters) long. Each rotor had a diameter of 47 feet, 0 inches (14.326 meters). It’s height was 15 feet, 6½ inches (4.737 meters). The helicopter’s empty weight was 4,470 pounds (2,028 kilograms) and its maximum gross weight was 8,800 pounds (3,992 kilograms).****

The H-43B was powered by one Lycoming T53-L-1B turboshaft engine, rated at 860 shaft horsepower at 21,510 r.p.m. The engine uses a 5-stage axial-flow, 1 stage centrifugal-flow, compressor with a single stage gas producer turbine and single-stage power turbine. A reverse-flow combustion section allows significant reduction in the the engine’s total length. The power turbine drives the output shaft through a 3.22:1 gear reduction. The T53-L-1 is 3 feet, 11.8 inches (1.214 meters) long and 1 foot, 11.0 inches (0.584 meters) in diameter. It weighs 460 pounds (209 kilograms).

The Huskie’s economical cruise speed was 98 miles per hour (158 kilometers per hour), and the maximum speed was 120 miles per hour (193 kilometers per hour). Its hover ceiling out of ground effect (HOGE) was 18,000 feet (5,486 meters), and in ground effect (HIGE) was 20,000 feet (6,096 meters) and it had a range of 235 miles (378 kilometers). Normal rotor speed in flight was 255–260 r.p.m., with a minimum 238 r.p.m. in autorotation.

Captain Coan was awarded the Distinguished Flying Cross for the record flight. Later as a major, he commanded Detachment 8, 38th Aerospace Rescue and Recovery Squadron, at Cam Ranh Bay Air Base during the Vietnam War. He retired from the Air Force at the rank of lieutenant colonel.

With the call sign Pedro, the HH-43 was a rescue helicopter that served in combat during the Vietnam War.

The record-setting Kaman HH-43B Huskie 60-0263 was last assigned to Detachment 3, 42nd Aerospace Rescue and Recovery Squadron, Kirtland Air Force Base, New Mexico. It is in the collection of the National Museum of the United States Air Force, Wright-Patterson Air Force Base, Ohio. Its distance record still stands.

Kaman HH-43B-KA Huskie 60-0263 at the National Museum of the United States Air Force. (U.S. Air Force)
Kaman HH-43B-KA Huskie 60-0263 at the National Museum of the United States Air Force. (U.S. Air Force)

¹ FAI Record File Number 1258

² FAI Record File Number 13154

³ FAI Record File Number 1870

⁴ FAI Record File Numbers 13057 and 13135

⁵ FAI Record File Numbers 13056 and 13136

⁶ FAI Record File Number 13137

⁷ FAI Record File Number 13208

**** Maximum overload gross weight is 9,150 pounds (4,150 kilograms) at a load factor of 2.0

© 2020, Bryan R. Swopes

22 May 1958

Aviation, , , , , , , , , , , , , , , ,
Colonel Edward Norris LeFaivre, United States Marine Corps.

22 May 1958: At NAS Point Mugu, a naval air weapons test center on the southern California shoreline, Major Edward Norris LeFaivre, United States Marine Corps, set five Fédération Aéronautique Internationale (FAI) World Records for Time to Altitude with a Douglas F4D-1 Skyray, Bureau of Aeronautics (“Bu. No.”) serial number 130745.

Runway 21 at Point Mugu (NTD) has a slight downhill gradient and the departure end is very near the shoreline, with an elevation of just 9 feet (2.7 meters). This runway has been used for time-to-altitude records on several occasions.

Douglas F4D-1 Skyray Bu. No. 130745 at NOTS China Lake, circa 1960. (China Lake Alumni)

Major LeFaivre’s Skyray climbed from the runway to 3,000 meters (9,843 feet) in 44.392 seconds ¹; 6,000 meters (19,685 feet), 1:06.095 ²; 9,000 meters (29,528 feet), 1:30.025 ³; 12,000 meters (39,370 feet), 1:51.244 ⁴; and 15,000 meters (49,213 feet), 2:36.233.⁵ This was the first time that a 15,000 meter had been set.

F4D-1 Bu. No. 130745 was the fifth production Skyray. The Douglas Aircraft Company F4D-1 Skyray was a single-place, single-engine, transonic all-weather interceptor, designed to operated from the United States Navy’s aircraft carriers. It had a tailless delta configuration with rounded wing tips. The Skyray was 45 feet, 7-7/8 inches (13.916 meters) long, with a wingspan of 33 feet, 6 inches (10.211 meters) and height of 12 feet, 11-7/8 inches (3.959 meters). The span with wings folded for storage on flight and hangar decks was 26 feet, 1-7/8 inches (7.972 meters), The wings’ leading edges were swept aft 52.5°. The total wing area was 557 square feet (51.747 square meters).

The interceptor had an empty weight of 16,024 pounds (7,268 kilograms) and maximum weight of 28,000 pounds (12,701 kilograms).

Early production F4D-1s were powered by a Pratt & Whitney J57-P-8 engine. The J57 was a two-spool axial-flow turbojet which had a 16-stage compressor section (9 low- and 7 high-pressure stages) and a 3-stage turbine (1 high- and 2 low-pressure stages). The J57-P-8 had a normal power rating of 8,700 pounds of thrust (38.70 kilonewtons) at 5,750 r.p.m. , N1. The military power rating was 10,200 pounds of thrust (45.37 kilonewtons) at 6,050 r.p.m., N1. Maximum power was 14,500 pounds of thrust (64.50 kilonewtons) at 6,050 r.p.m., N1, with afterburner. The engine was 3 feet, 4.5 inches (1.029 meters) in diameter, 20 feet, 10 inches (6.35 meters) long.

The cruise speed of the F4D-1 was 520 miles per hour (837 kilometers per hour). Its maximum speed was 722 miles per hour (1,162 kilometers per hour, or 0.95 Mach) at Sea Level, and 695 miles per hour (1,118 kilometers, or Mach 1.05) at 36,000 feet (10,973 meters). The Skyray had a service ceiling of 55,000 feet (16,764 meters), and maximum range of 1,200 miles (1,931 kilometers).

The F4D-1 was armed with four 20 mm Colt Mark 12 autocannon with 70 rounds per gun. The Mark 12 had a rate of fire of 1,000 rounds per minute. Four AAM-N-7 (AIM-9) Sidewinder infrared-homing air to air missiles could be carried under the wings, or various combinations of 2.75 inch rocket pods, up to a maximum of 76 rockets.

A U.S. Marine Corps Douglas F4D-1 Skyray, Bu. No. 134815, assigned to VMF(AW)-115, just south of the Palos Verdes Peninsula of Southern California, 4 April 1957. (Robert L. Lawson Collection, National Naval Aviation Museum)

The Skyray had very unpleasant handling characteristics. It was used to teach pilots how to handle unstable aircraft. Bu. No. 130745 was used as a flight test aircraft at NOTS China Lake, a Naval Ordnance Test Station near Ridgecrest, in the high desert of southern California. (China Lake, NID, is about 55 miles/89 kilometers north-northwest of Edwards AFB, EDW).

Lt. Jan M. Graves, USNR

On 21 October 1960, Lieutenant Jan Michael (“Black Jack”) Graves, United States Naval Reserve, was flying 130745, simulating aircraft carrier takeoffs from Runway 21 at China Lake. The F4D-1 had just taken off when, at approximately 100 feet (30.5 meters), it slowly rolled upside down and then crashed on to the runway. It slid about 1.14 miles (1.83 kilometers) before coming to  stop. Lieutenant Graves was killed.

Accident investigators found that a broken wire in the rudder feedback system had allowed the rudder to go to its maximum deflection.

As this Douglas F4D-1 Skyray dives away from the camera, its unusual delta wing planform can be seen. (United States Navy)

Edward Norris LeFaivre was born at Baltimore, Maryland, 11 October 1924. He attended the University of Maryland, graduating with a Bachelor of Science Degree. He was then employed at the Glenn L. Martin Company.

LeFaivre joined the United States Marine Corps in 1942. Trained as a Naval Aviator, he was assigned as a night fighter pilot with VMF(N)-533 at Yontan, Airfield, Okinawa. On 18 May 1945, Lieutenant LeFaivre shot down two enemy bombers with his Grumman F6F-5N Hellcat, for which he was awarded the Silver Star.

Captain LeFaivre continued as a night fighter pilot during the Korean War. Flying a Grumman F7F Tigercat assigned to VMF(AW)-513, on 21 October 1951, he repeatedly attacked a heavy concentration of enemy vehicles, LeFaivre’s airplane was shot down. He was rescued by helicopter, but his observer was listed as missing in action. Captain LeFaivre was awarded two additional Silver Stars for his actions on that night.

From 8 August to 31 December 1967, Colonel LeFaivre commanded Marine Air Group 13 (MAG-13), based at Chu Lai Air Base, Republic of South Vietnam. The group’s three squadrons were equipped with the McDonnell F-4B Phantom II.

Colonel Edward Norris LeFaivre retired from the Marine Corps in 1972. He died 28 June 1992 at the age of 68 years, and was buried at the Arlington National Cemetery, Arlington, Virginia.

¹ FAI Record File Number 8591

² FAI Record File Number 8592

³ FAI Record File Number 8593

⁴ FAI Record File Number 8594

⁵ FAI Record File Number 8595

© 2018, Bryan R. Swopes