Tag Archives: World Record for Altitude

23 March 1948

Aviation, , , , , , , , , , , , ,
John Cunningham with the record-setting de Havilland DH.110 Vampire (BNPS).
John Cunningham with the record-setting de Havilland DH.100 Vampire F.1, TG/278. Note the metal canopy with porthole. (BNPS).

23 March 1948: During a 45-minute flight over Hatfield, Hertfordshire, England, the de Havilland Aircraft Company chief test pilot, Group Captain John Cunningham, D.S.O., flew a modified DH.100 Vampire F.1 fighter to a Fédération Aéronautique Internationale (FAI) World Record for Altitude of 18,119 meters (59,446 feet).¹ Cunningham broke the record set nearly ten years earlier by Colonel Mario Pezzi in a Caproni Ca.161 biplane.² (See This Day in Aviation, 22 October 1938)

DH.100 Vampire F.1 TG/278 prior to high-altitude modifications. (de Havilland)
DH.100 Vampire F.1 TG/278 prior to high-altitude modifications. (de Havilland)

The de Havilland DH.100 Vampire F.1 flown by Cunningham was the fifth production aircraft, TG/278. It was built by the English Electric Company at Preston, Lancashire, with final assembly at Samlesbury Aerodrome, and made its first flight in August 1945. It was intended as a prototype photo reconnaissance airplane. The cockpit was heated and pressurized for high altitude, and a metal canopy installed.

The photo reconnaissance project was dropped and TG/278 became a test bed for the de Havilland Engine Company Ghost 2 turbojet (Halford H.2), which produced 4,400 pounds of thrust (19.57 kilonewtons) at 10,000 r.p.m. The Vampire could take the Ghost engine to altitudes beyond the reach of the Avro Lancaster/Ghost test bed already in use. The airplane’s wing tips were each extended 4 feet (1.219 meters) to increase lift.

De Havilland DH.100 Vampire F.1 TG/278 before the record flight. (De Havilland)
De Havilland DH.100 Vampire F.1 TG/278 after modifications. (de Havilland)

The aircraft was stripped of paint to reduce weight. Smaller batteries were used and placed in normal ballast locations. Special instrumentation and recording cine cameras were installed in the gun compartment, and ten cylinders of compressed air for breathing replaced the Vampire’s radio equipment. At takeoff, the Vampire carried 202 gallons (765 liters) of fuel, 40 gallons less than maximum, sufficient for only one hour of flight. The takeoff weight of TG/278 was 8,400 pounds (3,810 kilograms).

John Cunningham had previously flown TG/278 to a world record 799.644 kilometers per hour (496.876 miles per hour) over a 100 kilometer course at Lympne Airport, 31 August 1947.³

TG/278 continued as a test aircraft until it was damaged by an engine fire in October 1950. It was used as an instructional airframe at RAF Halton.

De Havilland DH.100 F Mk 1 Vampire TG/278 after high-altitude modifications (Vic Flintham)
De Havilland DH.100 Vampire F.1 TG/278 with high altitude modifications (de Havilland)

A standard Vampire F.1 was 9.370 meters (30 feet, 8.9 inches) long with a wingspan of 12.192 meters (40 feet, 0 inches) and overall height of 2.700 meters (8 feet, 10.3 inches). The fighter had an empty weight of 6,380 pounds (2,894 kilograms) and gross weight of 8,587 pounds (3,895 kilograms).

The basic Vampire F.1 was powered by a de Havilland-built Halford H.1B Goblin turbojet engine. This engine used a single-stage centrifugal-flow compressor and single-stage axial-flow turbine. It had a straight-through configuration rather than the reverse-flow of the Whittle turbojet from which it was derived. It produced 2,460 pounds of thrust (10.94 kilonewtons) at 9,500 r.p.m., and 3,000 pounds (13.34 kilonewtons) at 10,500 r.p.m. The Goblin weighed approximately 1,300 pounds (590 kilograms).

It had a maximum speed of 540 miles per hour (869 kilometers per hour), a service ceiling of 41,000 feet (12,497 meters) and range of 730 miles (1,175 kilometers).

The Vampire F.1 was armed with four 20 mm Hispano autocannon in the nose, with 150 rounds of ammunition per gun.

De Havilland DH.100 Vampire FB.5 three-view illustration with dimensions.
Group Captain John Cunningham, Royal Air Force. (Daily Mail)
Group Captain John Cunningham, Royal Air Force. (BNPS)

Group Captain John Cunningham C.B.E., D.S.O. and Two Bars, D.F.C. and Bar, A.E., D.L., F.R.Ae.S, was born 1917 and educated at Croydon. In 1935 he became an apprentice at De Havilland’s and also joined the Auxiliary Air Force, where he trained as a pilot. He was commissioned as a Pilot Officer, 7 May 1936, and was promoted to Flying Officer, 5 December 1937. Cunningham was called to active duty in August 1939, just before World War II began, and promoted to Flight Lieutenant, 12 March 1940.

While flying with No. 604 Squadron, Cunningham was awarded the Distinguished Flying Cross, 28 January 1941. He was appointed Acting Squadron Leader, Auxiliary Air Force, and was decorated with the Distinguished Service Order, 29 April 1941. The Gazette reported,

“This officer has continued to display the highest devotion to duty in night fighting operations. One night in April, 1941, he destroyed two enemy bombers during a single patrol and a week later destroyed  three enemy raiders during three different patrols. Squadron Leader Cunningham has now destroyed at least ten enemy aircraft and damaged a number of others. His courage and skill are an inspiration to all.”

—The London Gazette, 29 April 1941, Page 2445 at Column 1.

His Majesty George VI, King of the United Kingdom, greets Squadron Leader John Cunningham, D.S.O., D.F.C., 1941. (BNPS)

Acting Squadron Leader Cunningham’s promotion to Squadron Leader (Temporary) became official 10 June 1941. The King approved the award of a Bar to his Distinguished Flying Cross, 19 September 1941. Squadron Leader Cunningham took command of No. 604 Squadron 1 August 1946.

On 3 March 1944 Wing Commander Cunningham received a second Bar to his Distinguished Service Order. According to The Gazette,

“Within a recent period Wing Commander Cunningham has destroyed three more hostile aircraft and his last success on the night of 2nd January, 1944, brings his total victories to 20, all with the exception of one being obtained at night. He is a magnificent leader, whose exceptional ability and wide knowledge of every aspect of night flying has contributed in large measure to the high standard of operational efficiency of his squadron which has destroyed a very large number of enemy aircraft. His iron determination and unswerving devotion to duty have set an example beyond praise.”

—The London Gazette, 3 March 1944, Page 1059 at Column 1.

Promoted to Group Captain 3 July 1944, Cunningham was the highest scoring Royal Air Force night fighter pilot of World War II, credited with shooting down 20 enemy airplanes. He was responsible for the myth that eating carrots would improve night vision.

In addition to the medals awarded by the United Kingdom, he also held the United States Silver Star, and the Union of Soviet Socialist Republics Order of the patriotic War (1st Class).

Following the War, John Cunningham returned to de Havilland as a test pilot. After the death of Geoffrey Raoul de Havilland, Jr., in 1946, Cunningham became the de Havilland’s chief test pilot. He remained with the firm through a series of mergers, finally retiring in 1980.

Cunningham was appointed an Officer of the Most Excellent Order of the British Empire (O.B.E.) in 1951, and promoted to Commander of the Most Excellent Order of the British Empire (C.B.E.) in 1963. He relinquished his  Auxiliary Air Force commission 1 August 1967.

Group Captain John Cunningham C.B.E., D.S.O. and Two Bars, D.F.C. and Bar, A.E., D.L.,  died 21 July 2002 at the age of 84 years.

Wing Commander John Cunningham, D.S.O. and two bars, D.F.C. and Bar, A.E., Auxiliary Air Force. (Test and Research Pilots, Flight Test Engineers)

¹ FAI Record File Number 9844

² FAI Record File Number 11713: 17,083 meters (56,047 feet)

³ FAI Record File Number 8884

© 2019, Bryan R. Swopes

6 March 1931

Aviation, , , , , , , , , , , ,
Ruth Nichols (1901–1960)
Ruth Rowland Nichols (1901–1960)

6 March 1931: Ruth Rowland Nichols set a Fédération Aéronautique Internationale (FAI) World Altitude Record of 8,761 meters (28,743 feet) at Jersey City Airport, New Jersey.¹

Nichols’ airplane was a 1928 Lockheed Model 5 Vega Special, serial number 619, registered NR496M, and owned by Powell Crosley, Jr. He had named the airplane The New Cincinnati.

Built by the Lockheed Aircraft Company, Burbank, California, the Vega was a single-engine high-wing monoplane with fixed landing gear. It was flown by a single pilot and could be configured to carry four to six passengers.

The Lockheed Vega was a very state-of-the-art aircraft for its time. The prototype flew for the first time 4 July 1927 at Mines Field, Los Angeles, California. It used a streamlined monocoque fuselage made of molded plywood. The wing and tail surfaces were fully cantilevered, requiring no bracing wires or struts to support them. The fuselage was molded laminated plywood monocoque construction and the wing was cantilevered wood.

The Model 5 Vega is 27 feet, 6 inches (8.382 meters) long with a wingspan of 41 feet (12.497 meters) and overall height of 8 feet, 2 inches (2.489 meters). Its empty weight is 2,595 pounds (1,177 kilograms) and gross weight is 4,500 pounds (2,041 kilograms).

Nichols’ airplane was powered by an air-cooled, supercharged 1,343.804-cubic-inch-displacement (22.021 liter) Pratt & Whitney Wasp C, a nine-cylinder radial engine with a compression ratio of 5.25:1. It was rated at 420 horsepower at 2,000 r.p.m. at Sea Level. The engine drove a two-bladed controllable-pitch Hamilton Standard propeller through direct drive. The Wasp C was 3 feet, 6.63 inches (1.083 meters) long, 4 feet, 3.44 inches (1.307 meters) in diameter and weighed 745 pounds (338 kilograms).

Ruth Nichols with man holding barograph after setting FAI World Altitude Record. (FAI)
Ruth Nichols with Walter D. Wood, National Aeronautic Association, who is holding the sealed barograph after setting FAI World Altitude Record. (FAI)

Flying the Vega, Ruth Nichols also set records for speed between New York and Los Angeles. NR496M was damaged beyond repair at Floyd Bennett Field, 11 April 1931.

“Ruth Nichols was the only woman to hold simultaneously the women’s world speed, altitude, and distance records for heavy landplanes. She soloed in a flying boat and received her pilot’s license after graduating from Wellesley College in 1924, becoming the first woman in New York to do so. Defying her parents wishes to follow the proper life of a young woman, in January 1928 she flew nonstop from New York City to Miami with Harry Rogers in a Fairchild FC-2. The publicity stunt brought Nichols fame as “The Flying Debutante” and provided headlines for Rogers’ airline too. Sherman Fairchild took note and hired Nichols as a northeast sales manager for Fairchild Aircraft and Engine Corporation. She helped to found the Long Island Aviation Country Club, an exclusive flying club and participated in the 19,312-kilometer (12,000-mile) Sportsman Air Tour to promote the establishment of clubs around the country. She was also a founder of Sportsman Pilot magazine. Nichols set several women’s records in 1931, among them a speed record of 339.0952 kph (210.704 mph), an altitude record of 8,760 meters (28,743 feet), and a nonstop distance record of 3182.638 kilometers (1,977.6 miles). Her hopes to become the first woman to fly the Atlantic Ocean were dashed by two crashes of a Lockheed Vega in 1931, in which she was severely injured, and again in 1932. In 1940, Nichols founded Relief Wings, a humanitarian air service for disaster relief that quickly became an adjunct relief service of the Civil Air Patrol (CAP) during World War II. Nichols became a lieutenant colonel in the CAP. After the war she organized a mission in support of the United Nations Children’s Fund (UNICEF) and became an advisor to the CAP on air ambulance missions. In 1958, she flew a Delta Dagger at 1,609 kph (1,000 mph) at an altitude of 15,544 meters (51,000 feet). A Hamilton variable pitch propeller (which allowed a pilot to select a climb or cruise position for the blades), from her Lockheed Vega is displayed in the Golden Age of Flight gallery. Nichols’ autobiography is titled Wings for Life.”

— Smithsonian Institution National Air and Space Museum, Women In Aviation and Space History, The Golden Age of Flight.

Ruth Nichols with her Lockheed Model 5a Vega.
Ruth Nichols with the Lockheed Model 5 Vega Special. (National Air and Space Museum, Smithsonian Institution)

¹ FAI Record File Number 12228

© 2018, Bryan R. Swopes

27 February 1920

Aviation, , , , , , , , , , ,
Major Rudolph William Schroeder, Air Service, United States Army

27 February 1920: Major Rudolph William Schroeder, Chief Test Pilot of the Engineering Division, McCook Field, Ohio, flew a Packard Lepère L USA C.II biplane to a Fédération Aéronautique Internationale (FAI) World Record Altitude of 10,093 meters (33,114 feet).¹ The biplane was powered by a turbosupercharged Liberty L-12 aircraft engine producing 443 horsepower.

There are differing accounts of what occurred during the flight. One report is that the L USA C.II created the very first contrail as it flew at altitudes and temperatures never before reached. Also, there are differences in explanations of some type of problem with Major Schroeder’s oxygen supply. A valve may have frozen, the regulator did not operate correctly, or one of his tanks was empty. Another source says that he ran out of fuel. But he apparently suffered hypoxia and began to lose consciousness. He may have lost control, or intentionally dived for lower altitude. The airplane dived nearly 30,000 feet (9,144 meters) before Schroeder pulled out and safely landed. He was in immediate need of medical attention, however.

Recording instruments indicated that he had been exposed to a temperature of -67 °F. (-55 °C.). His goggles had iced over, and when he raised them, his eyes were injured by the severe cold.

Schroeder’s barograph recorded a peak altitude of 37,000 feet (11,277.6 meters). When the device was calibrated after landing, it indicated that his actual maximum altitude was 36,020 feet (10,979 meters).

The Fédération Aéronautique Internationale (FAI) delegated responsibility for certifying the record to the Aero Club of America, whose representatives apparently felt that procedures for setting the record had not been correctly followed, and declined to accept the altitude record.

The National Bureau of Standards next evaluated the data and credited Rudolph Schroeder with having reached 33,180 feet (10,113 meters). Regardless, the current official record altitude, according to FAI, remains 10,093 meters (33,114 feet).

Major Rudolph W. Schroeder, USAAC, flying a Packard Lepère LUSAC 11 over McCook Filed, Ohio, 24 September 1919. (U.S. Air Force)
Major Rudolph W. Schroeder flying a Packard Lepère L USA C.II, A.S. 40015,  over McCook Field, Ohio, 24 September 1919. (U.S. Air Force)

The Packard Lepère L USA C.II was a single-engine, two-place biplane fighter which was designed by the French aeronautical engineer, Capitaine Georges Lepère, who had previously designed the Section Technique de l’Aeronautique Dorand AR.1 reconnaissance airplane for France’s military air service. The new airplane was built in the United States by the Packard Motor Car Company of Detroit, Michigan. It was a two-place fighter, or chasseur, light bomber, and observation aircraft, and was armed with four machine guns.

The L USA C.II was 25 feet, 3-1/8 inches (7.699 meters) long. The upper and lower wings had an equal span of 41 feet, 7¼ inches (12.681 meters), and equal chord of 5 feet, 5¾ inches (1.670 meters). The vertical gap between the wings was 5 feet, 1/8-inch (1.527 meters) and the lower wing was staggered 2 feet, 15/16-inch (0.633 meters) behind the upper wing. The wings’ incidence was +1°. Upper and lower wings were equipped with ailerons, and had no sweep or dihedral. The height of the Packard Lepère, sitting on its landing gear, was 9 feet, 7 inches (2.921 meters).

Packard Lepère L USA C.II P53, A.S. 40015, left profile. The turbocharger is mounted above the propeller driveshaft. (U.S.. Air Force)

The fuselage was a wooden structure with a rectangular cross section. It was covered with three layers of veneer, (2 mahogany, 1 white wood) with a total thickness of 3/32-inch (2.38 millimeters). The fuselage had a maximum width of 2 feet, 10 inches (0.864 meters) and maximum depth of 4 feet, 0 inches (1.219 meters).

The wings were also of wooden construction, with two spruce spars and spruce ribs. Three layers of wood veneer covered the upper surfaces.

The Packard Lepère had an empty weight of 2,561.5 pounds (1,161.9 kilograms) and its gross weight was 3,746.0 pounds (1,699.2 kilograms).

The Packard Lepère was powered by a water-cooled, normally-aspirated, 1,649.34-cubic-inch-displacement (27.028 liter) Packard-built Liberty 12 single overhead cam (SOHC) 45° V-12 engine, which produced 408 horsepower at 1,800 r.p.m., and drove a two-bladed, fixed-pitch propeller with a diameter of 9 feet, 10 inches (2.997 meters). The Liberty 12 was 5 feet, 7.375 inches (1.711 meters) long, 2 feet, 3.0 inches (0.686 meters) wide, and 3 feet, 5.5 inches (1.054 meters) high. It weighed 844 pounds (383 kilograms).

The engine coolant radiator was positioned horizontally in the center section of the airplane’s upper wing. Water flowed through the radiator at a rate of 80 gallons (303 liters) per minute.

Packard-Lèpere L USA C.II P53, A.S. 40015. (U.S. Air Force)

The L USA C.II had a maximum speed of 130.4 miles per hour (209.9 kilometers per hour) at 5,000 feet (1,524 meters), 127.6 miles per hour (205.4 kilometers per hour) at 10,000 feet (3,048 meters), 122.4 miles per hour (197.0 kilometers per hour) at 15,000 feet (4,572 meters), 110.0 miles per hour (177.0 kilometers per hours) at 18,000 feet (5,486 meters) and 94.0 miles per hour (151.3 kilometers per hour) at 20,000 feet (6,096 meters). Its cruising speed was 112 miles per hour (180 was kilometers per hour). The airplane could climb to 5,000 feet in 4 minutes, 24 seconds, and to 20,000 feet in 36 minutes, 36 seconds. In standard configuration, the LUSAC 11 had a service ceiling of 20,200 feet (6,157 meters). Its range was 320 miles (515 kilometers).

Packard Lepère L USA C.II, P54, S.C. 42138. (U.S. Air Force)

Armament consisted of two fixed M1918 Marlin .30-caliber machine guns mounted on the right side of the fuselage, synchronized to fire forward through the propeller arc, with 1,000 rounds of ammunition, and two M1918 Lewis .30-caliber machine guns on a flexible mount with 970 rounds of ammunition.

The Air Service had ordered 3,525 of these airplanes, but when the War ended only 28 had been built. The contract was cancelled.

The only Packard Lepère L USA C.II in existence, serial number A.S. 42133, is in the collection of the National Museum of the United States Air Force, Wright-Patterson Air Force Base, Ohio.

Packard Lepère LUSAC 11, S.C. 42133, at the National Museum of the United States Air Force. (U.S. Air Force)
Packard Lepère L USA C.II, A.S 42133, at the National Museum of the United States Air Force. (U.S. Air Force)

¹ FAI Record File Number 8229: 10 093 m (33,114 feet)

© 2018, Bryan R. Swopes

19–20 February 1979

Aviation, , , , , , , , , , , , ,
Professor Neil A. Armstrong in his classroom at the Iniversity of Cincinatti College of Engineering, 1974. (Peggy Palange, UC Public Informaton Office)
Professor Neil A. Armstrong in his classroom at the University of Cincinnati College of Engineering, 1974. (Peggy Palange, UC Public Information Office)

19–20 February 1979: Professor Neil Alden Armstrong of the University of Cincinnati College of Engineering, a member of the Board of Directors of Gates Learjet Corporation, former United States Navy fighter pilot, NACA/NASA research test pilot, Gemini and Apollo astronaut, and The First Man To Set Foot On The Moon, set five Fédération Aéronautique Internationale (FAI) and National Aeronautics Association class records for time to climb to an altitude and altitude while flying the prototype Learjet 28, serial number 28-001.

Professor Neil Armstrong and co-pilot Peter Reynolds in the cockpit of the record-setting Learjet 28, March 1979.
Professor Neil Armstrong and co-pilot Peter Reynolds in the cockpit of the record-setting Learjet 28.

Armstrong, with Learjet program test pilot Peter Reynolds as co-pilot, and with NAA observer Don Berliner aboard, flew the Learjet 28 to 15,000 meters (49,212.598 feet) in 12 minutes, 27 seconds over Kittyhawk, North Carolina, on 19 February.¹

On the same day, during a flight from Wichita, Kansas, to Elizabeth City, North Carolina, Armstrong flew the Learjet to 15,584.6 meters (51,130.577 feet), setting records for altitude, and for sustained altitude in horizontal flight.²  ³

The following day, 20 February 1979, flying from Elizabeth City, North Carolina, to Florence, Kentucky, Armstrong again set altitude and sustained altitude in horizontal flight, in a different class, by taking the Learjet to 15,585 meters (51,131.89 feet).⁴ ⁵

Learjet 28, serial number 28-001
Learjet 28, serial number 28-001. (NASA)

The Learjet 28 was a development of the Learjet 25 twin-engine business jet. It is operated by two pilots and can carry 8 passengers. The Model 28 used a new wing design. It was the first civil aircraft to be certified with winglets. The prototype first flew 24 August 1977, and it received certification from the Federal Aviation Administration 29 July 1979.

The Learjet 28 is 47 feet, 7.5 inches (14.516 meters) long with a wingspan of 43 feet, 9½ inches (13.348 meters) and overall height of 12 feet, 3 inches (3.734 meters). The wing area is 264.5 square feet (24.6 square meters) It has an empty weight of 7,895 pounds (3,581 kilograms) and maximum takeoff weight of 15,000 pounds (6,804 kilograms).

Gates Learjet 28 three-view illustration. (FLIGHT International, No. 3647, Vol. 115, 10 February 1979, Page 402)

The Learjet 28 is powered by two General Electric CJ610-8A turbojet engines. This is a single-shaft axial-flow turbojet, developed from the military J85. It has an 8-stage compressor section and 2-stage turbine. The CJ610-8A is rated at 2,850 pounds of thrust (12.68 kilonewtons) at 16,500 r.p.m., and 2,950 pounds (13.12 kilonewtons) at Sea Level, for takeoff (five minute limit).

The business jet has a cruise speed of 464 knots (534 miles per hour (859 kilometers per hour) at 51,000 feet (15,544.8 meters). The Learjet 28 has a maximum range of 1,370 nautical miles (1,577 statute miles/2,537 kilometers). The airplane’s maximum operating altitude is 51,000 feet (15,545 meters), the same as the record altitude. It can reach that altitude in less than 35 minutes.

The aircraft was limited by its older technology turbojet engines, and only five Learjet 28s were built.

Gates Learjet 28 N128LR. (Business Aviation Online)

The first Learjet 28, serial number 28-001, has been re-registered several times. At the time of its FAI record-setting flights, it carried FAA registration N9RS. Later it was registered as N3AS. The most recent information shows it currently registered as N128LR.

The record-setting Learjet 28 is in the collection of the Armstrong Air & Space Museum, Wapakoneta, Ohio.

Neil Alden Armstrong, one of America’s most loved heroes, passed away 25 August 2012.

A bronze statue of Neil Alden Armstrong in front of the Hall of Engineering.
A bronze statue of Neil Alden Armstrong in front of the Hall of Engineering.

¹ FAI Record File Number 2652

² FAI Record File Number 8670

³ FAI Record File Number 8657

⁴ FAI Record File Number 2653

⁵ FAI Record File Number 2654

© 2019, Bryan R. Swopes

10 February 1947

Aviation, , , , , , , , , , ,
Major E.M. Cassell, USAF. (FAI)
Major Ernest M. Cassell, Jr., Air Corps, United States Army. (FAI)

10 February 1947: At Patterson Field, Dayton, Ohio, Major Ernest Murray Cassell, Jr., Air Corps, United States Army, flew a Sikorsky YR-5A helicopter, serial number 43-46628, to an altitude of 5,842 meters (19,167 feet), setting a Fédération Aéronautique Internationale (FAI) World Altitude Record for helicopters.¹

Major Cassell took off from Patterson Field at 11:05 a.m., and landed at 12:02 p.m. He said that he knew the helicopter had reached its absolute ceiling. “She just wouldn’t go any higher. At the peak I dived to pick up speed, pulled up and the ship just quivered in a tip-stall as if to say, ‘That’s all I can do.’ ”

At that altitude, Cassell encountered winds of 40–50 miles per hour (18–22 meters per second), and an air temperature of -19 °C. (-2.2 °F.). He wore an electrically-heated flight suit.

Cassell was one of the most experienced helicopter pilots in the U.S. military services, with more than 700 hours flown to date.

Observers for the National Aeronautic Association, Dr. Daniel P. Johnson of the National Bureau of Standards, and C.S. Logsdon, director of the contest division of the N.A.A., flew aboard a North American Aviation B-25 Mitchell medium bomber. The B-25 flew along with the helicopter. Both carried barographs. A second B-25 acted as the camera ship.

The Sikorsky YR-5A (Model S-48) was a single-engine, two-place helicopter. The cabin was built of aluminum with plexiglas windows. The fuselage was built of plastic-impregnated plywood and the tail boom was wood monocoque construction. The main rotor consisted of three fully-articulated blades built of wood spars and ribs and covered with fabric. The three bladed semi-articulated tail rotor was built of laminated wood. The main rotor turned counter-clockwise as seen from above. (The advancing blade is on the helicopter’s right.) The tail rotor was mounted on the helicopter’s left side in a pusher configuration. It turned clockwise as seen from the helicopter’s left.

YR-5A 43-46608 was one of one of twenty-six service test helicopters built between November 1944 and July 1945. There were slight changes from the earlier five XR-5A prototypes. The R-5A went into production in July 1945 and more than 300 had been built by the time production ended in 1951.

The helicopter’s fuselage was 41 feet, 7½ inches (12.687 meters) long. The main rotor had a diameter of 48 feet, 0 inches (14.630 meters) and tail rotor diameter was 8 feet, 5 inches (2.565 meters), giving the helicopter an overall length of 57 feet, 1 inch (17.399 meters) with rotors turning. It was 13 feet, 1½ inches (4.001 meters) high. The landing gear tread was 12 feet (3.7 meters). The R-5A had an empty weight of 3,780 pounds (1,715 kilograms) and maximum takeoff weight of 4,900 pounds (2,223 kilograms). Fuel capacity was 100 gallons (378.5 liters).

Sikorsky S-48 (R-5) three-view illustration with dimensions. (Sikorsky Historical Archives)

The helicopter was powered by an air-cooled, supercharged, 986.749-cubic-inch-displacement (16.170 liter) Pratt & Whitney Wasp Jr. T1B4 (R-985 AN-5) direct-drive, nine-cylinder radial engine which was placed vertically in the fuselage behind the crew compartment. This engine was rated at 450 horsepower at 2,300 r.p.m., Standard Day at Sea Level. The R-985 AN-5 was 4 feet, 0.00 inches (1.219 meters) long, 3 feet, 10.25 inches (1.175 meters) in diameter and weighed 684 pounds (310.3 kilograms) with a magnesium crankcase.

The R-5 had a maximum speed (Vne) of 107 knots (123.1 miles per hour/198.2 kilometers per hour). Range was 275 miles (442.6 kilometers). The service ceiling was 14,800 feet (4,511 meters). The absolute hover ceiling was 3,000 feet (914.4 meters).

Sikorsky YR-5A 43-46628. (FAI)
Sikorsky YR-5A 43-46628. (FAI)

Ernest Murray Cassell, Jr., was born at Indianapolis, Indiana, 26 February 1912. He was the first of two sons of Ernest Murray Cassell, a traveling salesman, and Irene Eidola Adams Cassell.

Ernest Cassell served in the United States Navy as a seaman, first class, from 14 February 1931 to 3 December 1934. He enlisted as a private in the Indiana National Guard (Air Corps) on 11 March 1935. He was commissioned as a second lieutenant, 11 March 1937.

Lieutenant Cassell graduated from the National Guard Officers’ Communication Course of the Air Corps Technical School in 1938. He was rated as an aerial observer.

Lieutenant Cassell married Miss Virginia Royall Fleming, in Marion County, Indiana, 31 March 1938. They would have two children, Judith Ann Cassell and Nicholas Murray Cassell.

On 17 January 1941, Cassell was commissioned as a second lieutenant, Air Corps, Army of the United States (A.U.S.). He was promoted to first lieutenant, 25 March 1941, and to captain, 12 December 1942. On 26 June 1944, Captain Cassell was promoted to the rank of major, A.U.S.

On 10 February 1947 (the date of his altitude record flight) Cassell as appointed to the permanent rank of 1st lieutenant, Air Corps, United States Army, with date of rank retroactive to 26 February 1940. Less than three weeks later, 26 February 1947 (his 35th birthday), Cassel was promoted to captain.

Following the establishment of the United States Air Force as a separate military service, Captain Cassell was transferred from the Air Corps, U.S. Army, to the U.S. Air Force. His date of rank was 26 February 1947.

Lieutenant Colonel Ernest Murray Cassell, Jr., retired from the United States Air Force on 3 February 1959. He died at Walter Reed Medical Center, Washington, D.C., 2 December 1959. He was buried at Arlington National Cemetery, Arlington, Virginia.

¹ FAI Record File Number 2256

© 2019, Bryan R. Swopes